CRC SmartWasher SW-23 Manual

6
Contact CRC Industries at 800-556-5074 | smartwasher.com
Installation and Setup Continued
CHECK LOCAL REGULATIONS:
You may be able to dispose of your used OzzyMat
®
as solid waste or with your other absorbent mats.
OzzyJuice
®
Degreasing Solution
The SmartWasher
®
uses a specially formulated uid which
provides a combination of excellent cleaning characteristics,
safety and nutrition for the Ozzy
®
microbes. OzzyJuice
®
is
provided in ready-to-use containers.
Adding OzzyJuice
®
Slowly pour a full container of OzzyJuice
®
directly into the
SmartWasher
®
sink. The “add uid light” should go out
when you have completed this process.
To help monitor and maintain the proper uid level, the
SmartWasher
®
is equipped with an “add uid light”.
When the “add uid light” light comes on the heater in
the unit will turn off until an ENTIRE 5 Gallon container of
OzzyJuice
®
is added.
The “add uid light” light will shut off and the heater will
come back on once the 5 Gallon container of OzzyJuice
®
is
added to the SmartWasher
®
.
Temperature Settings
• Your SmartWasher
®
should be plugged in 24 hours a day,
7 days a week to maintain optimal temperature.
• Depending on the OzzyJuice
®
solution shipped with your
SmartWasher
®
, the thermostat is factory-set to maintain
uid temperature between 105°F (+-2°) (40°C) (+-1°)
AND 115°F (+-2°) (46°C) (+-1°). This temperature provides
the optimum condition for effective cleaning and activity
of Ozzy
®
microbes.
• The heater will not operate when the uid level becomes
critically low. Lift the sink and check your uid level.
When the “add uid light” illuminates add 1 (5) gallon
container of OzzyJuice
®
. If, after a reasonable warm-up
period, the uid temperature seems too hot or too cold,
please refer to the “Troubleshooting” section of this
manual.
• If the temperature falls below the recommended
minimum, the system will still clean, but remediation
of the hydrocarbons by the Ozzy
®
microbe colony will
slow down. However, the microbes will not die. The
Ozzy
®
colony will become more active when the uid
temperature reaches the appropriate level.
Visit Smartwasher.com for videos
and product information.
Pump Switch
Up: 10 minutes
Down: 30 minutes
Temperature Switch
Up: 105°F
Down: 115°F

CRC SmartWasher SW-23 Specifications

General

Brand	CRC
Model	SmartWasher SW-23
Category	Washer
Language	English