Crusader Challenger 5.7L Catanium CES - Safety and Regulatory Information; Proposition 65 Warning

86 pages

Save Page as PDF

To Next Page

To Previous Page

WARNING

The engine exhaust from this product

contains chemicals known to the State of

California to cause cancer, birth defects or

other reproductive harm.

PROPOSITION 65

Main Page

Default Chapter5
- Table of Contents5
Introduction7
- Registration Information (Warranty Registration Card Is Located at the Back of this Manual)7
- 3-Year Transferable Limited Warranty8
- Federal/California Emission Control Warranty Statement9
- Crusader Challenger Inboard Marine Engine General Emissions Warranty Coverage10
- Safety Information13
- Replacement Parts13
- Safety Warnings13
- Introduction13
Boating Responsibility14
- Carbon Monoxide Hazard14
- Safe Boating Suggestions15
- Water Wisdom15
- Operation and Maintenance15
- Rules of the Road16
Engine Identification17
- Owner Identification and Registration Information17
- Engine Model Identification / Advisory18
Electronic Fuel Injection Information19
- Electronic Fuel Injection System19
Operating Instructions20
- Engine Alarm System20
- Instrumentation21
- Electronic Speed Control21
- Starting Engine (Fuel Injected Engines)21
- Shifting Transmission23
- Stopping Engine24
- Freezing Temperature Operation24
- Operation in High Debris Areas24
- Challenger Speed Control System25
Conditions Affecting Operation27
- Weight Distribution27
- Boat Bottom27
- Propeller Selection27
Engine Break-In Period28
25-Hour Engine Inspection29
Fuel Requirements30
- Gasoline Requirements30
- Gasoline Containing Alcohol30
Oil Requirements31
- Engine Oil Recommendations31
- Transmission and "V"-Drive Oil Requirements31
Engine Maintenance32
- Checking Fluid Levels32
- Lubrication34
- Electrical System Relay and Fuse Block35
- Electrical System Fuses35
- Boat's Ignition Fuse35
- Electrical System Wiring and Connectors35
- Battery35
- Fuel System Description40
- Fuel Control Cell (FCC) Fuel System40
- In-Tank High Pressure Fuel Pump System40
- Servicing the FCC41
- Primary Fuel Filter (FCC Clamp-On Canister)41
- Servicing Fuel Pre-Filter43
- Priming Fuel System43
- Flame Arrestor43
- Accessory Drive Belt44
- Servicing Raw Water Pump Impeller45
- Changing Oils46
- Engine Alignment47
- Engine Maintenance Log51
- Maintenance Schedule52
- Maintenance Schedule53
- Visual Inspection54
- Engine Fluid Capacities54
- Transmission Fluid Capacities54
- Filter and Accessory Requirements55
- Engine Maintenance55
Engine Specifications56
- Engine Specifications58
Out-Of-Season Storage59
- Engine Storage59
- Draining Instructions60
- Battery Storage60
- Out-Of-Season Engine Warm-Up61
- Recommissioning after Storage61
- Out-Of-Season Storage61
Troubleshooting62
Water Flow Diagrams65
Heater Connections74
Instrumentation Wiring Diagram76
Literature77
Forms78
Notes82

Crusader Challenger 5.7L Catanium CES - Safety and Regulatory Information; Proposition 65 Warning

Table of Contents

Related product manuals