Name: Crusader Challenger 5.7L Catanium CES
Brand: Crusader
Rating: 5 (1 reviews)

To Next Page

To Previous Page

L510032-16

ENGINE SPECIFICATIONS - 12

MODEL ALL

Coolant 200°F

Over-Temperature DTC 116/217

Sensor Check Gauges Lamp

and Buzzer

Engine Derates

Exhaust Manifold Varies with Application

Water Temperature DTC 1415/1416/

Sensors 1417/1418

Check Gauges Lamp

and Buzzerr

Low Oil < 5 psi @ idle /

Pressure Sensor < 24 psi @ 4000

DTC 524

Check Gauges Lamp

and Buzzer

CHALLENGER MASTER WARNING/ALARM SPECIFICATIONS

NOTE: FOR NEW BOAT PROPPING, IT IS RECOMMENDED THAT OEMS PROP TO THE

MAXIMUM RPM LISTED.

Default Chapter5
- Table of Contents5
Introduction7
- Registration Information (Warranty Registration Card Is Located at the Back of this Manual)7
- 3-Year Transferable Limited Warranty8
- Federal/California Emission Control Warranty Statement9
- Crusader Challenger Inboard Marine Engine General Emissions Warranty Coverage10
- Safety Information13
- Replacement Parts13
- Safety Warnings13
- Introduction13
Boating Responsibility14
- Carbon Monoxide Hazard14
- Safe Boating Suggestions15
- Water Wisdom15
- Operation and Maintenance15
- Rules of the Road16
Engine Identification17
- Owner Identification and Registration Information17
- Engine Model Identification / Advisory18
Electronic Fuel Injection Information19
- Electronic Fuel Injection System19
Operating Instructions20
- Engine Alarm System20
- Instrumentation21
- Electronic Speed Control21
- Starting Engine (Fuel Injected Engines)21
- Shifting Transmission23
- Stopping Engine24
- Freezing Temperature Operation24
- Operation in High Debris Areas24
- Challenger Speed Control System25
Conditions Affecting Operation27
- Weight Distribution27
- Boat Bottom27
- Propeller Selection27
Engine Break-In Period28
25-Hour Engine Inspection29
Fuel Requirements30
- Gasoline Requirements30
- Gasoline Containing Alcohol30
Oil Requirements31
- Engine Oil Recommendations31
- Transmission and "V"-Drive Oil Requirements31
Engine Maintenance32
- Checking Fluid Levels32
- Lubrication34
- Electrical System Relay and Fuse Block35
- Electrical System Fuses35
- Boat's Ignition Fuse35
- Electrical System Wiring and Connectors35
- Battery35
- Fuel System Description40
- Fuel Control Cell (FCC) Fuel System40
- In-Tank High Pressure Fuel Pump System40
- Servicing the FCC41
- Primary Fuel Filter (FCC Clamp-On Canister)41
- Servicing Fuel Pre-Filter43
- Priming Fuel System43
- Flame Arrestor43
- Accessory Drive Belt44
- Servicing Raw Water Pump Impeller45
- Changing Oils46
- Engine Alignment47
- Engine Maintenance Log51
- Maintenance Schedule52
- Maintenance Schedule53
- Visual Inspection54
- Engine Fluid Capacities54
- Transmission Fluid Capacities54
- Filter and Accessory Requirements55
- Engine Maintenance55
Engine Specifications56
- Engine Specifications58
Out-Of-Season Storage59
- Engine Storage59
- Draining Instructions60
- Battery Storage60
- Out-Of-Season Engine Warm-Up61
- Recommissioning after Storage61
- Out-Of-Season Storage61
Troubleshooting62
Water Flow Diagrams65
Heater Connections74
Instrumentation Wiring Diagram76
Literature77
Forms78
Notes82

Questions and Answers:

Need help?

Do you have a question about the Crusader Challenger 5.7L Catanium CES and is the answer not in the manual?

Crusader Challenger 5.7L Catanium CES Specifications

General

Brand	Crusader
Model	Challenger 5.7L Catanium CES
Category	Engine
Language	English

Related product manuals

Challenger 6.0L Catanium CES

86 pages

Crusader MP 5.0L

157 pages

Crusader Challenger 5.7L Catanium CES User Manual

Table of Contents

Questions and Answers:

Crusader Challenger 5.7L Catanium CES Specifications

Related product manuals