Datex-Ohmeda Tec 5 - Page 5

Contents 2 Tec 5 Vaporizer
August 1999 O & M Manual Part No. 1105-0100-000
Contents
Page
7.2.3 Barometric Pressure............................................................................26
7.2.4 Back Pressure (Steady)........................................................................27
7.2.4.1 Low And Moderate Pressures27
7.2.4.2 High Pressures 27
7.2.5 Back Pressure (Fluctuating).................................................................27
7.2.6 Carrier Gas Composition......................................................................27
7.2.7 Time Out Of Service.............................................................................27
7.2.8 Other Variables.....................................................................................28
8.0 Checking The Calibration ...................................28
9.0 Analytical Techniques .......................................29
10.0 Specification ..................................................30
10.1 Calibration.............................................................................................30
10.2 Resistance To Gas Flow With Vaporizer Out Of Circuit......................30
10.3 Liquid Capacity.....................................................................................30
10.4 Weight And Dimensions......................................................................30
10.5 Environmental Conditions....................................................................30
10.6 Performance.........................................................................................30
11.0 Warranty .......................................................31
Illustrations
Fig. 1 Vaporizer Identification Label................................................................4
Fig. 2 Vaporizer Mounting Procedure..............................................................5
Fig. 3 Locking The Vaporizer On To A Manifold..............................................5
Fig. 4 Turning ON The Vaporizer......................................................................6
Fig. 5 Unlocking The Vaporizer From A Manifold............................................6
Fig. 6 Filling A Vaporizer Which Incorporates A Screw Cap Filler..................7
Fig. 7 Draining A Vaporizer Which Incorporates A Screw Cap Filler..............8
Fig. 8 Filling A Vaporizer Which Incorporates A Keyed Filler..........................9
Fig. 9 Draining A Vaporizer Which Incorporates A Keyed Filler...................10
Fig.10 Filling A Vaporizer Which Incorporates A Quik-Fil™ Filler.................11
Fig.11 Draining A Vaporizer Which Incorporates A Quik-Fil™ Filler.............12
Fig.12 Vaporizer Interlock Mechanism...........................................................15
Fig.13 Two Vaporizers Locked On To The Manifold -
Both Turned OFF...................................................................................16
Fig.14 Two Vaporizers Locked On To The Manifold -
Vaporizer A Turned ON........................................................................16
Fig.15 Manifold By-pass Circuit......................................................................17
Fig.16 Vaporizers Flow - Schematic Diagram................................................19
Fig.17 Tec 5 Vaporizer Gas Flow.....................................................................20