Dea LIVI 803E - 9NET - Risk-Free Operation Guidelines; Spare Parts List; Complete Closing Assembly; Safety Edge and Impact Protection

L I V I
Operatinginstructionsandwarnings
8
WARNINGWrongassessmentofimpactforcesmaycause
seriousdamagetopeople,animalandthings.DEASystemre-
mindsallpersonnelthattheinstallermustascertainthatthese
impactforces,measuredaccordingtoEN12445prescriptions,
areactuallybelowthelimitsindicatedbyEN14453regulation.
WARNINGInlinewithEUDirective2002/96/ECforwaste
electricalandelectronicequipment(WEEE),thiselectricalpro-
ductmustnot bedisposedof asunsorted municipal waste.
Please dispose of this product by returning it to your local
municipalcollectionpointforrecycling.
3 MODELS AND CONTENTS
OF THE PACKAGE
ThenameLIVIidentifiesaseriesofelectromechanicalopera-
torswithdifferentfeaturesastomotorandcontrolboardpower
supplyvoltage,rangeofbuilt-inorexternalcontrolboardand
mechanical adjustment of force, electronic clutch and built-in
limitswitch.DEASystemarticlesintheseriesarelistedinthe
“AVAILABLEMODELS”table.LIVIiscompletedbyasetofacces-
sorieslistedinthe“PRODUCTACCESSORIES”table.Inspectthe
“ContentsofthePackage”onPage30andcompareitwithyour
productforusefulconsultationduringassembly.
4 OPERATING INSTRUCTIONS
IncompliancewithDirective2006/42/CEEnclosureI,Point
1.7.4.
4.1 Product description
LIVI is an electro-mechanical operator designed for the
automation of  sliding gates. LIVI is basically made up of a
mechanical gear motor (vedi F1 pag. 30) rotating the draft
gearthat,in associationtoaproperlyinstalledrack,converts
the circular movement of the gear motor into straight-line
movement, thus allowing the gate to move in its own slide.
4.2 Technical data
Seethe“TECHNICALDATA”table.
4.3 Labelling information
PartofthesummariseddatafortheCElabelarelistedinthe
labelappliedtotheproduct(seePositionF5,Page30);thedata
regardingthe sellerarefoundin theenclosedWarranty,whi-
le“IndispensableOperatingSafetyElements”arefoundunder
Point“4.2Technicaldata”.
4.4 Appropriate conditions of use
TheLIVIis designedfor installationinsliding gatesas an
actuatorfortheoperationalautomatismasshowninF3onPage
31.Bracketsforboth“horizontal”(standard)and“vertical”(see
“PRODUCTACCESSORIES”table)installationhavebeenarran-
gedfor.TheLIVI hasbeendesignedandtested foroperation
under “normal”civil gate openingconditions;temperature li-
mits,degreesofprotection againstdustandwater,andother
data are provided in Point 4.2 “Technical Data”. Satisfactory
operationrequires thecorrectpositioningofthe LIVIoperator
withrespecttothegate;DEASystemrecommendedmeasure-
mentsareshowninF3page31.Theautomatismrequiredmust
beselectedaccordingtothegatetobemoved;theattritionon
theattachments,theweight,thelength/heightofthegatewing,
andthedegreeofclosingofthesurfacesaretheelementstobe
considered.
WARNINGTheuseoftheproductunderunusualconditions
notforeseenbythemanufacturercancreatesituationsofdan-
ger,andforthisreasonalltheconditionsprescribedinthese
instructionsmustberespected.
WARNING Under no circumstances must the product be
usedinexplosiveatmospheresorsurroundingsthatmayprove
corrosiveanddamagepartsoftheproduct.
“PRODUCT ACCESSORIES” table
Article
Code
Description
111
619000
Nylon rack
112
126001
Zinc plated rack
22x22
113
126000
Zinc plated rack
30x12
460
619010
Foundation base
to be cemented
403E-6NET 803E-9NET 5/24NET/F 8/24NET/F
Motorpowersupplyvoltage(V) 230V~±10%(50/60Hz) 24V
Absorbedpower(W) 320 450 80 110
MaxThrust(N) 340 490 210 260
Workcycle(leafL=5m) 18cycles/hour 11cycles/hour 22cycles/hour 18cycles/hour
Maxn°ofoperationsin24hour
(leafL=5m)
60 40 60 40
Built-incapacitor(µF) 8 12,5 -
Operatingtemperaturerange(°C) -20÷40°C
Motorthermalprotection(°C) 140°C 160°C -
Openingspeed(m/min) 10
Weightofproductwithpackage(Kg) 11 12,5 12
Protectiondegree IPX4