Dixie Chopper Iron Eagle 2350 - Routine Maintenance; Daily Checks; Every 25 Hours Maintenance; Every 250 Hours or Annually Maintenance

20
Dixie Chopper • 6302 E. County Road 100 N. • Coatesville, IN • 46121 • www.dixiechopper.com
Routine Maintenance
NOTE: The recommended Transaxle oil for your Dixie Chopper machine is Lucas 20/50 Plus Motor Oil (Part Num-
ber 20500). We strongly urge that you use this oil in the event that you should need to refi ll or add to your hydraulic
reservoir.
Engine Oil: Under Normal Mowing Conditions, Use Lucas 15/40.
For Cold Weather Operation, Consult Engine Manual.
Lube Grease: Lucas X-tra H/D Grease part# 10301.
Daily
Checks
Check
Engine Oil Level
Follow Manufacturer’s
Recommendations
Check
Transaxle Oil Level
Lucas 20/50 Plus Motor Oil
Check
Tire Pressure
Rear Tires: 7 psi
Front Tires: 12 ps
i
Every 25
Hours
Change
Engine Oil and Filter
Follow Manufacturer’s
Recommendations
Replace
Air Filter
(DO NOT BLOW OUT WITH COM-
PRESSED AIR)
Check
Engine to Transaxle
Belt Tension
Tension Spring compressed to 2”
Check
Battery Fluid Level
(If applicable)
Check
Engine to Mower Deck Tension
Tension Spring compressed to 3”
Lube
Deck Spindle Assemblies
Every 250
Hours or
Annually
Change
Hydraulic Filters
Remove Belts and Check
Spindle Bearings, Idlers, and Pulleys.
Change
Transaxle Oil
Lucas 20/50 Plus Motor Oil
Change every
400
hours or annually
Lube
Front Caster Bearings
Clean or Replace
Spark Plugs
Check
Steering for Creep in the Neutral Position
Check
Front and Rear Tires
for Tread Wear
Replace
Engine Fuel Filter(s)
Change
Transaxle Drive Oil
DO NOT USE HYDRAULIC OIL, HYTRAN, OR AUTOMATIC TRANSMISSION FLUID.
USE Lucas 20/50 Plus Motor Oil or a HIGH-GRADE 10W50, 15W40, 15W50, OR 20W50
MOTOR OIL
OF 89 SUS or BETTER AT 212
DEGREE FARENHEIT
i