EasyManua.ls Logo

DUROMAX XP10000EH-05072020 - User Manual

DUROMAX XP10000EH-05072020
82 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
XP10000EH GENERATOR
This manual provides information regarding the operation
and maintenance of these products. We have made every
effort to ensure the accuracy of the information in this
manual. We reserve the right to change this product at
any time without prior notice.
5800 Ontario Mills Pkwy
Ontario, CA 91764 USA
www.duromaxpower.com
Call our Customer Care Team Toll Free 8-5pm PST Mon-Fri
844-DUROMAX
User Manual
*Gasoline & Propane Tank Not Included
REV: XP10000EH-05072020

Table of Contents

Questions and Answers

  • J
    Jay LeeAug 8, 2025
    Why won't my DUROMAX Portable Generator start?
    • B
      beverlycarrAug 8, 2025
      Your DUROMAX Portable Generator might not start due to several reasons: the engine switch is off (set it to 'run'), the fuel valve is closed (turn it to 'open'), the choke is open (close it), the engine is out of fuel (add fuel), the fuel is old or contaminated (change fuel), the spark plug is dirty (clean it), the spark plug is broken (replace it), the generator is not level (move it to a level surface), or the oil is low (add/change oil).
  • M
    Michael WashingtonAug 17, 2025
    What to do if my DUROMAX XP10000EH-05072020 Portable Generator runs, but there is no electrical output?
    • C
      Crystal MorenoAug 17, 2025
      If your DUROMAX Portable Generator runs but provides no electrical output, check if the circuit breaker is off and turn it on. Also, a bad wiring connection could be the cause, so replace the extension cord(s). Finally, the device connected to the generator might be malfunctioning, in which case you should disconnect it.
  • S
    Stephen GarrettAug 27, 2025
    How to resolve DUROMAX Portable Generator running, but not supporting all connected electrical devices?
    • S
      Steven AlexanderAug 27, 2025
      If your DUROMAX Portable Generator runs but can't support all connected devices, it might be overloaded. Try disconnecting one or more items to reduce the load. Alternatively, a connected device might be faulty, so disconnect any malfunctioning devices. A dirty air cleaner can also cause this issue; clean or replace the air filter.

Summary

Introduction

General Safety Procedures

Essential safety guidelines and warnings for generator operation and handling.

Quick Start Guide (Gasoline)

Step-by-step instructions for starting the generator using gasoline.

Quick Start Guide (Propane)

Step-by-step instructions for starting the generator using propane.

Generator Setup

Remove Shipping Braces

Instructions for safely unpacking and removing shipping restraints from the generator.

Wheel Kit Installation (Optional)

Guide for assembling the optional wheel kit for generator portability.

Connect the Battery

Procedure for connecting the generator's internal battery for electric start.

Adding Oil

Instructions on how to properly add the correct amount of engine oil.

Adding Gasoline (Optional)

Steps for safely adding gasoline to the generator's fuel tank.

Grounding the Generator

Critical steps for properly grounding the generator to prevent electrical hazards.

High Altitude Operation

Guidance on generator performance and modifications for high altitude use.

Starting the Generator

Before You Start Your Generator

Pre-operation checks including oil and gas level verification.

Check the Gas Level (Optional)

Procedure to verify the gasoline level in the fuel tank.

Starting the Generator Using Gasoline

Detailed steps for initiating the generator engine using gasoline.

Starting the Generator Using Propane

Detailed steps for initiating the generator engine using propane.

Starting the Generator Using Recoil Start

Instructions for starting the generator manually using the recoil pull cord.

Using the Generator

AC Usage

Guidelines for connecting AC-powered devices and understanding wattage.

Connecting a Load to the Generator

How to properly connect electrical devices to the generator's outlets.

Voltage Selector Switch

Explanation of the Power Boost technology and voltage selection.

Choosing the Right Power Cord

Recommendations for selecting appropriate power cords based on gauge and length.

DC Usage

Instructions for using the DC receptacle for battery charging.

Maintenance and Care

Maintenance Schedule

Recommended service intervals for engine oil, air cleaner, and other components.

Maintenance Log

A log to record performed maintenance activities and dates.

Checking the Oil

Procedure for verifying the engine oil level before operation.

Changing the Oil

Steps for draining and refilling the engine oil.

Cleaning the Air Filter

Instructions for cleaning and maintaining the air filter element.

Spark Plug Maintenance

Guide for inspecting, cleaning, gapping, and replacing the spark plug.

Emptying the Gas Tank

Procedure for draining the fuel tank for storage.

Cleaning the Fuel Filter Cup

Steps for removing and cleaning the fuel filter cup.

Storage and Transportation

Guidelines for safely storing and transporting the generator.

Troubleshooting

Changing; Inspecting the Carbon Brushes

Procedure for inspecting and replacing generator carbon brushes.

Changing; Inspecting the AVR

Guide for inspecting and replacing the Automatic Voltage Regulator (AVR).

Warranty

3-year Warranty

Details of the standard 3-year parts warranty for residential use.

Warranty Exclusions

Conditions and situations not covered by the generator warranty.

Warranty Limitations

Limitations on liability for damages or losses related to product use.

U.S EPA and California Emission Control Warranty Statement

Explanation of emission control system warranty rights and obligations.

Defects Warranty Requirements

Specific requirements and conditions for warranty claims and coverage.

Exhaust Emission Warranty Parts List

List of components covered under the exhaust emission warranty.

Customer Service

DUROMAX XP10000EH-05072020 Specifications

General IconGeneral
Starting Wattage10, 000 Watts
Running Wattage8, 000 Watts
Engine Type4-Stroke OHV
Engine Displacement439cc
Fuel TypeGasoline
Fuel Tank Capacity8.3 Gallons
Weight224 lbs
Voltage120V/240V
Noise Level72 dB
Wheel KitYes
Starting SystemElectric Start / Recoil Start
DC Output12V
Outlet Types12V DC

Related product manuals