MAINTENANCE SCHEDULEMAINTENANCE SCHEDULE
To keep your motorcycle safe and reliable when you ride, regular inspections and service is required. Below you
will nd a maintenance schedule that describes when components need to be inspected or serviced. e main-
tenance schedule lists item that can be performed with basic mechanical skills and hand tools. In addition, the
maintenance schedule will list items that involve more extensive procedures and could require special training,
tools and/or equipment.
Because this motorcycle does not have an odometer, service intervals in the maintenance schedule are expressed
in terms of riding days. To avoid missing required maintenance, we suggest that you develop a good way to record
the amount of time you spend riding your monocycle. If you do not feel capable of performing any of the pro-
cedures described in this manual or if you need assistance, please contact your nearest Egl MotorEgl Motor dealer. If you
decide to do your own maintenance, use only replacement parts that you have purchased from a Egl MotorEgl Motor dealer
or parts purchased directly from Egl MotorEgl Motor. is will ensure the best quality and reliability for your motorcycle.
Always perform the pre-ride inspection described on page 20 at each scheduled maintenance interval.
Each item on the maintenance schedule requires some mechanical knowledge. You will nd that some items in
the table (marked* and**) may require a higher level of mechanical skill and special tools. If you do not feel capa-
ble of performing any procedure, please consult your nearest Egl MotorEgl Motor dealer.
* Indicates items that require a moderate to high level of mechanical skill. We recommend service by a Egl Motor Egl Motor
dealer if the owner is not mechanically qualied.
** Indicates items and procedures that require special tools.
Note: Service your motorcycle more frequently when you ride in wet or dusty conditions.
Maintenance Procedures: I = Inspect (clean, adjust or replace if needed), C = Clean, A = Adjust, L = Lubricate,
R = Replace
MAINTENANCE ITEMS
HOURS 10 30 50 70 90 110 130
ENGINE OIL R R R R R R R
AIR FILTER I,C R I,C R I,C R I,C
ENGINE OIL FILTER C C R C C R C
ENGINE VALVE CLEARANCE I I
**
SPARK PLUG I I R I I R I
FUEL FILTER I I C I I C I
FUEL LINE I I I I I I I
THROTTLE ASSEMBLY I I I I I I I
SECONDARY AIR SUPPLY I I I I I I I
ENGINE IDLE SPEED I,A I,A I,A I,A I,A I,A I,A
DRIVE CHAIN I,C I,C I,C I,C I,C I,C I,C
DRIVE CHAIN SLIDER I I I I I I I
BRAKE PAD WEAR I I I I I I I
BRAKE SYSTEM I I I I I I I
CLUTCH I I I I I I I
**
SIDE STAND I I I I I I I
SUSPENSION I I I I I I I
**
MUFFLER
I
I
I
I
I
I
I
NUTS,BOLTS,FASTENERS I I I I I I I
WHEELS,TIRES I I I I I I I
SUSPENSION BUSHINGS/BEARINGS I I I I I I I
**
To Next Page
Loading...