3156-VOLT LITHIUM-ION ELECTRIC LAWN TRACTOR — TR4200E
TROUBLESHOOTING
PROBLEM CAUSE SOLUTION
The electric lawn tractor fails to
drive when the accelerator pedal is
depressed.
◾
The combined Ah of the inserted
batteries does not meet the
requirement.
◾
In order to start this tractor, use enough EGO batteries
following the instructions in section “ATTACHING/
DETACHING THE BATTERY PACK” in this manual.
◾
The parking brake pedal is set in the
braking position.
◾
Fully depress the parking-brake pedal to release it from
the parking-brake position.
◾
The tractor status indicator does not
shine green.
◾
Depress the parking-brake pedal and then release. The
tractor status indicator will shine green, which means the
tractor is ready to start.
◾
The operator is not sitting on the seat.
◾
The tractor can only be operated, when the operator is
properly sitting on the seat.
◾
The seat safety interlock system is not
connected properly.
◾
Remove the batteries from the tractor and lift the back
of the seat up to make sure that the cable plug is
properly connected to the socket on the bottom of the
seat (seechapter “INSTALLING THE SEAT”). Follow the
instructions in “STARTING THE TRACTOR” to restart the
tractor to see if the tractor can be started. If not, please
contact EGO customer service centre for repair.
◾
Under extreme cold weather,
the driving function may not
start successfully due to the low
temperature protection.
◾
Always store the tractor and batteries in warm
environment. Restart the tractor when it is warmed up.
Please do not make repeated attempts under extreme
cold weather which may damage the machine.
◾
The travel path of the accelerator
pedal is clogged with debris.
◾
Check and remove the debris
◾
Failure of mechanical or electronic
components of the accelerator pedal.
◾
Contact EGO customer service centre for repair.
◾
The direction control lever is placed in
the neutral position.
◾
Push/pull the direction control lever in the “D” or “R”
direction.
The electric lawn tractor stops
driving.
◾
When switching between forward and
reverse during driving, the direction
control lever stays in the neutral
position for long time.
◾
Release the accelerator pedal and then depress it again.
◾
Failure of electronic components of the
accelerator pedal.
◾
Contact EGO customer service centre for repair.
◾
The seat safety interlock system got
disconnected during driving on a rough
terrain.
◾
Remove the batteries from the tractor and lift the back
of the seat up to make sure that the cable plug is
properly connected to the socket on the bottom of the
seat (seechapter “INSTALLING THE SEAT”). Follow the
instructions in “STARTING THE TRACTOR” to restart the
tractor to see if the tractor can be started. If not, contact
EGO customer service centre for repair.
◾
The operator’s weight is not evenly
distributed on the seat. The weight of
the operator on the seat must be at
least 20 kg for the seat safety interlock
system to function properly.
1. Sit on the seat properly, fully depress the parking-brake
pedal and release it, then the tractor is ready for driving.
2. Disconnect and attach the batteries again if necessary.
◾
The parking-brake pedal is depressed
enough but not locked to the parking
position, the tractor will stop.
◾
Follow the instructions in “STARTING THE TRACTOR” to
restart the tractor.
To Next Page
Loading...
