Equalizer Systems Auto Level - Troubleshoot Manual

Other manuals for Equalizer Systems Auto Level

Operation And Warranty Guide14 pages

Installation Guide23 pages

Basic Troubleshooting4 pages

Questions and Answers

H
hollowaynicholasSep 6, 2025
Why is my Equalizer Systems Lifting Systems keypad not turning on?
- D
  Derek PorterSep 6, 2025
  The keypad might not be turning on due to several reasons. It could be a blown fuse at the pump harness, which requires a fuse replacement. Alternatively, there might be a faulty ground or power wire that needs tracing and repair. A low battery voltage could also be the culprit, so ensure the chassis and/or coach batteries are charged. In some cases, a defective keypad or controller, or a defective keypad or controller harness might be the reason; these would need to be traced and repaired.
O
Olivia MeyerAug 22, 2025
How to fix Equalizer Systems Auto Level Automobile Accessories keypad that will not turn on?
- B
  bvillarrealAug 22, 2025
  If the keypad for your Equalizer Systems Automobile Accessories won't turn on, here are a few things to check: * **Blown fuse:** Replace the fuse at the pump harness or in the fuse panel. * **Wiring:** Look for and repair any faulty ground or power wires. * **Battery:** Charge the chassis and/or coach batteries if the voltage is low. * **Keypad harness:** Check keypad harness and repair if necessary.
A
anita35Sep 3, 2025
What to do if Equalizer Systems Auto Level Automobile Accessories jacks will not retract from full extension?
- B
  Bradley EdwardsSep 4, 2025
  If the jacks on your Equalizer Systems Automobile Accessories will not retract from full extension, check the following: * **Defective pump motor or solenoid:** Replace the motor and/or solenoid. * **Low battery voltage or poor ground:** Charge the chassis and/or coach batteries and ensure proper grounding to the keypad. * **Damaged or defective harness:** Trace and repair the harness from the keypad to the pump. * **Low fluid level:** Check the fluid level and add as necessary.
M
Mr. Allen BoydSep 2, 2025
What does it mean if the jack LED’s on the panel stay on for Equalizer Systems Automobile Accessories?
- R
  Regina RiveraSep 2, 2025
  If the jack LED’s on the panel of your Equalizer Systems Automobile Accessories stay on, it could be due to: * **Defective Pressure Switch or wiring:** Trace and repair or replace the pressure switch or wiring. * **Low system pressure:** Correct any leaks or low fluid levels causing low system pressure.
K
Kyle MolinaSep 1, 2025
Why will AUTO-LEVEL not level on my Equalizer Systems Automobile Accessories?
- G
  George StevensonSep 1, 2025
  If the AUTO-LEVEL on your Equalizer Systems Automobile Accessories will not level, check these items: * **System Null:** Set the Null. * **Controller:** Check the controller orientation; it may be installed improperly or has moved. * **Ignition Switch:** Check and change the ignition switch position as needed.
A
Andrea WhiteAug 30, 2025
What causes Equalizer Systems Automobile Accessories jacks to not operate when the keypad is on?
- R
  Ronald FryeAug 30, 2025
  If the keypad turns on, but the jacks on your Equalizer Systems Automobile Accessories will not operate, consider the following: * **Low Battery Voltage:** Charge chassis and/or coach batteries. * **Faulty electrical connection:** Trace and repair. * **Defective pump motor or solenoid:** Replace the defective pump motor or solenoid.
A
Alicia MillerAug 29, 2025
Why does AUTO-LEVEL stop mid-cycle on my Equalizer Systems Auto Level?
- D
  Douglas MooneyAug 29, 2025
  If the AUTO-LEVEL system on your Equalizer Systems Automobile Accessories stops mid-cycle, check the following: * **Low battery voltage:** Charge the chassis and/or coach batteries. * **Excessive vehicle motion:** Reset the control keypad and retry if there was excessive vehicle motion. * **System Null:** Set the Null if it has not been set. * **Controller:** Check and replace the controller if it is damaged or defective.
M
Matthew CollinsAug 27, 2025
What to do if Equalizer Systems Auto Level jacks retract but won't extend?
- S
  Stacey ReedAug 27, 2025
  If the jacks on your Equalizer Systems Automobile Accessories will retract but not extend, consider the following: * **Low Battery Voltage:** Charge the chassis and/or coach batteries. * **Park Brake:** Ensure the park brake is set. * **Birotational Pump:** Replace the motor and/or solenoid if you have a birotational pump with a bad motor or solenoid. * **Anti-Twist Software:** Lower the opposite side of the coach and/or reset Null and Level Coach if the Anti-Twist Software Protocol has been initiated. * **Ignition Switch:** Check and change the ignition switch position as needed. * **Faulty electrical connection:** Trace and repair faulty electrical connection.
J
Jonathon MercadoAug 27, 2025
Why are the jacks jerky when retracting on my Equalizer Systems Auto Level Automobile Accessories?
- R
  Raymond WallaceAug 27, 2025
  If the jacks on your Equalizer Systems Automobile Accessories retract jerkily, it might be due to: * **Air in the system:** Purge the air from the hydraulic system. * **Low fluid level:** Check the fluid level and add fluid as necessary.
R
Richard RochaAug 25, 2025
Why Equalizer Systems Auto Level Automobile Accessories jacks will extend but will not retract?
- T
  Tammy RhodesAug 26, 2025
  If the jacks on your Equalizer Systems Automobile Accessories will extend but not retract, here are some possible causes: * **Low battery voltage:** Charge the chassis and/or coach batteries. * **Incorrect hose connection:** Check and repair the hose connection at the pump or jack. * **Faulty wire or valve:** Check and repair DV1, looking for faulty wires or valves.

Summary

Operation

Manual Operation using the Equalizer Systems Auto-Level keypad

Explains manual operation of auto-level keypad.

Planting the jacks

Details extending jacks to contact the ground.

Leveling the coach

Guides on using keypad buttons to level the vehicle.

Retracting the jacks

Procedure for retracting jacks before travel.

Auto-Level Operation

Power on

Front Jacks

Auto-Level

Retracting the Jacks

Setting the Null

Manual Override Procedure

To operate your jack(s) using the manual override

Troubleshooting Guide

Keypad will not turn on

Lists possible causes and fixes for keypad power issues.

Keypad turns on, Jacks will not operate

Identifies issues when keypad is active but jacks don't respond.

Jacks will retract but will not extend

Addresses problems with jacks retracting but failing to extend.

Jacks will extend but will not retract

Troubleshoots jacks that extend but cannot be retracted.

Auto-Level will not level

Covers causes and solutions for the auto-level function failing.

Auto-Level stops mid-cycle

Troubleshooting steps for when auto-leveling process halts unexpectedly.

Hydraulic pump inoperative

Identifies and resolves problems with the hydraulic pump.

Jack(s) bleed down from leveled or stowed position

Solutions for jacks losing height after being set.

Jack(s) will not retract from extended position

Troubleshoots jacks stuck in the extended position.

Equalizer Systems Limited Warranty Policy

Warranty Claims and Authorization

Warranty Coverage Period

Labor and Freight Reimbursement

Warranty Labor Authorization

Equalizer Systems Auto Level Specifications

General

Category	Automobile Accessories
Installation	Professional installation recommended
Type	Automatic Leveling System
Operation	Automatic
Compatibility	Various RV and trailer models

Related product manuals

AUTO-LEVEL 3103

8 pages