EasyManua.ls Logo

EXPERT GRILL GBC1846WS - User Manual

EXPERT GRILL GBC1846WS
12 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
™
OWNER’S MANUAL
Table of Contents
Important Safeguards ...........................................................Page 2
Limited Warranty .................................................................. 3
Expanded View & Hardware .......................................................... 4
Assembly Instructions............................................................... 5
Installing LP Gas Tank............................................................... 8
Operating Instructions............................................................... 9
Cleaning and Care ................................................................ 10
Troubleshooting .................................................................. 12
The use and installation must conform with local codes or, in the absence of local codes, with either the
National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1,
or Propane Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/
NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP
FOR FUTURE REFERENCE.
If you are assembling this unit for someone else, give this manual to them to read and save for future
reference.
California Proposition 65: Combustion by-products produced when using this product contain chemicals
known to the State of California to cause cancer, birth defects, and other reproductive harm.
California Proposition 65: Wash your hands after handling this product.
California Proposition 65: Handling the brass material on this product exposes you to lead, a chemical
known to the State of California to cause cancer, birth defects, or other reproductive harm.
Manufactured in China for: RevoAce Inc. Limited
Hong Kong, China
Outdoor LP Gas Barbecue Grill
Model No. GBC1846WS
.
.
Never operate this appliance unattended.
.
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
.
FOR YOUR SAFETY:
1. Improper installation, adjustment,
alteration, service or maintenance can
cause injury or property damage.
2. Read the installation, operation, and
maintenance instructions thoroughly
before installing or servicing this
equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could
cause property damage, personal injury, or
death.
4. This instruction manual contains Important
information necessary for the proper
assembly and safe use of the appliance.
5. Read and follow all warnings and
instructions before assembling and using
the appliance.
6. Follow all warnings and instructions when
using the appliance.
7. Keep this manual for future reference.
.
FOR YOUR SAFETY:
1. Do NOT store or use gasoline or other
flammable liquids or vapors in the vicinity
of this or any other appliance.
2. An LP cylinder not connected for use shall
NOT be stored in the vicinity of this or any
other appliance.
If you smell gas -
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
If you have questions or need assistance during assembly,
please call 1-800-694-0013.
GBC1846WS-OM-E-F105

Table of Contents

Questions and Answers

  • M
    Melissa JohnsonAug 14, 2025
    How to fix EXPERT GRILL GBC1846WS Grill burner that won't light with igniter?
    • M
      Matthew Butler Jr.Aug 14, 2025
      If the burner on your EXPERT GRILL Grill won't light using the igniter, there are several potential causes and solutions: * Ensure the LP gas tank valve is open and the regulator is securely attached. * If the LP gas tank is low or empty, exchange, refill, or replace it. * In case of an LP gas leak, close the tank valve and wait 5 minutes before checking for leaks. * Clean any cooking residue from the wires or electrode with rubbing alcohol. * Dry the electrode and burners with a cloth if they are wet. * For cracked or broken electrodes, loose or disconnected wires, shorting wires, or a bad igniter, replacement parts may be needed.
  • I
    ibarrastacyAug 17, 2025
    Why does the flame keep going out on my EXPERT GRILL GBC1846WS Grill?
    • J
      John AyalaAug 17, 2025
      The flame on your EXPERT GRILL Grill might be going out due to: * High or gusting winds - avoid using the grill in high winds. * Low LP Gas - exchange, refill, or replace the LP gas tank. * The overfilling prevention device may have been activated - refer to 'Sudden drop in gas flow or reduced flame height'.
  • T
    Toni HillAug 21, 2025
    What to do if I have a flare-up on my EXPERT GRILL GBC1846WS Grill?
    • N
      nwilliamsAug 21, 2025
      If you experience a flare-up on your EXPERT GRILL Grill, it could be due to grease buildup, excess fat in the meat, or excessive cooking temperature. To resolve this: * Remove and clean all grill parts. * Trim fat from meat before grilling. * Adjust to a lower cooking temperature.
  • M
    Mary HammondAug 25, 2025
    Why is there a sudden drop in gas flow on my EXPERT GRILL GBC1846WS Grill?
    • D
      donaldmclaughlinAug 25, 2025
      A sudden drop in gas flow or reduced flame height on your EXPERT GRILL Grill could be due to: * Being out of gas - exchange, refill, or replace the LP gas tank. * The overfilling prevention device being activated. To reset it: 1. Turn control knobs to ' OFF'. 2. Wait 30 seconds and light grill. 3. If flames are still too low, reset the overfilling prevention device: * Turn control knob(s) ' OFF'. * Turn LP gas tank valve to 'CLOSED'. * Disconnect regulator. * Turn control knobs to (HIGH). * Wait 1 minute. * Turn control knobs to ' OFF'. * Reconnect regulator and leak check connections, being careful not to fully open valve. * Light grill.
  • P
    paul70Aug 28, 2025
    Why is the flame yellow or orange on my EXPERT GRILL GBC1846WS Grill?
    • R
      rschneiderAug 28, 2025
      A yellow or orange flame on your EXPERT GRILL Grill may be caused by: * Residual manufacturing oils on a new burner - burn the grill for 15 minutes on high with the lid closed. * Spider webs or insect nests in the venturi - clean the venturi. * Food residue, grease, etc. on burners - clean the burner. * Poor alignment of valve to burner/venturi tube - ensure the burner/venturi tube is properly engaged with the valve.
  • M
    Miranda CunninghamAug 30, 2025
    What causes an irregular flame pattern on my EXPERT GRILL GBC1846WS Grill?
    • S
      Samantha RossAug 31, 2025
      An irregular flame pattern, where the flame does not run the full length of the burner on your EXPERT GRILL Grill, is typically caused by clogged or blocked burner ports. Clean the burner ports to resolve this issue.
  • A
    amanda24Sep 3, 2025
    What to do with a persistent grease fire in my EXPERT GRILL GBC1846WS?
    • T
      Taylor HickmanSep 3, 2025
      If you have a persistent grease fire in your EXPERT GRILL Grill, it's likely due to grease trapped by food buildup around the burner system. Here's how to handle it: * Turn control knobs to ' OFF'. * Turn LP gas tank valve to 'CLOSED'. * Leave lid in closed position and let fire burn out. * After grill cools, remove and clean all parts.
  • N
    nicholasbrownSep 6, 2025
    What causes flashback in EXPERT GRILL Grill burner tubes?
    • G
      Guy SantosSep 6, 2025
      Flashback, or fire in the burner tubes of your EXPERT GRILL Grill, is caused by blocked burners and/or burner/venturi tubes. Clean the burners and/or burner/venturi tube to resolve this.
  • J
    jessicanunezSep 10, 2025
    Why is the inside of my EXPERT GRILL GBC1846WS lid peeling?
    • J
      johnbaileySep 10, 2025
      If the inside of your EXPERT GRILL Grill lid is peeling, it's likely due to baked-on grease buildup that has turned to carbon and is flaking off. Clean all grill parts to resolve this.

Summary

Important Safeguards

Important Safeguards

LP Gas Characteristics

Properties of LP gas, including flammability, odor, and handling hazards.

LP Gas Cylinder Safety

Requirements and precautions for using LP gas cylinders, including OPD and storage.

Important Safeguards

General Grill Safety Precautions

Rules for safe operation, cleaning, maintenance, and fire prevention.

Limited Warranty

Grill Parts and Expanded View

Assembly Hardware

List and specifications of hardware components used in assembly.

Required Assembly Tools

Tools required or included for the assembly process.

Assembly Instructions

Assembly Tips and Preparation

Advice for a smooth and safe assembly process, including workspace and part layout.

Assembly Instructions

Assembly Instructions

Installing LP Gas Tank

LP Gas Tank Connection and Disconnection

Procedures for safely connecting and disconnecting the LP gas tank.

Operating Instructions

Gas Leak Detection Procedure

Methods for detecting gas leaks before and during operation using a soap solution.

Lighting the Main Burners

Step-by-step guide for igniting the primary grill burners, including backup methods.

Managing Flare-ups

Techniques to manage and prevent excessive flare-ups during cooking.

Operating Instructions

Side Burner Operation

Instructions for using the auxiliary side burner, including lighting and cooking.

Cleaning and Care

General Cleaning and Care

Precautions and procedures for cleaning the grill surfaces and components.

Main Burner Cleaning

Steps to clean the primary burners and ensure proper function and flame.

Cleaning and Care

Side Burner Cleaning

Instructions for cleaning the side burner assembly and its components.

Grill Storage Preparation

Procedures for preparing the grill for storage, including cleaning and disconnecting the tank.

Troubleshooting

Troubleshooting: Burner Ignition Issues

Common causes and solutions when the burner fails to ignite.

Troubleshooting: Gas Flow Reduction

Diagnosing and resolving issues with sudden drops in gas flow or reduced flame height.

Troubleshooting: Flame Extinguishment

Troubleshooting steps for when the flame extinguishes during operation.

EXPERT GRILL GBC1846WS Specifications

General IconGeneral
TypeGas Grill
Fuel TypePropane
Burners4
Burner MaterialStainless Steel
MaterialSteel
FeaturesSide Burner

Related product manuals