Ford THUNDERBIRD 1960 User Manual

P.ie
REMOVAL AND DISASSEMBLY
I RemovAl and Disassentbly 4-6
2 Assembly and
mat allat ion
. 4-7
A single water pump assembly is
used and is
shown dtaanmbled in
Eig.
1, The pump is equipped with a
soaled bearing integral
with
the water
pump shaft. ‘rise bearing requires tao
lubrication. Th hole in the
Wa
Icr
punip
huicaing Fig, 4 is a bleed hole
to al tow water that may leak past the
teal
to he thrown out by the slio ger.
This is not a Ic.bricdtiun hole.
REMOVAL
I. Drain the cooling system. Re.
move the generator adjusting arm
bolt’ at the generator and I 00w n the
adjusting arm
bolt at tlte
watet pump,
Loosen the we generator mounting
bolts at the bracket. Move the
gen
cralor inward and remove the fan
hells.
2. Diacoooect the radii tar lower
hose and heater hose at the water
pump.
On 152
C
tij
tie loosen the rue!
pump
astern bly re
Is ii og boILs and
slide the fuel pump out’ on he hdts
SHAFT AN:
SSARINO
SLINGtR
HOt
PUMP 500?
o rae
inch
for
access to the water Pu FTtP
lower left retaining bolt.
3. Remove the generator bracket
retaining bolt at the water pump.
Loosen the generator bracket retain.
jog bolt at the cylinder block and
move the bracket away from the
water pump.
4. Loosen and nave the water
pump by-pass hose front clamp
to
the rear. Retunve the boIls retmilniag
the water pump to
the
l,locL,
aitd re
move thc water pump assembly and
gaskets.
S. Remove thc fan, spacer, and
Pul te,, Remo vu the generator adj
StM
OA5Et
4
ing arm retaining bolt and renanve
the arm from the pump.
DISASSEMBLY
1. Remove the back plate and gas
kct from the
water pump, then
re
move ‘he hU from
the i napelle.r shaft
Fig. 2.
2. Position the
pump on an arbor
prc.sa and prea.s the shaft off the I
pcllor and out of
the housing Fig,
3.
3. l’ress out the
pump seal
hug,
4I,
FIG. 2-Rub Removal
FIG. 3-shaft
Remova’
p,.55 Re,,
.0 0,
t,*5 Cc
I
nAsKtt
iMr’eLLn
51199_A
FIG. 1 -Typiccl Woten Pump Assembly
FIG. 4-Seol
Removal

Ford THUNDERBIRD 1960 Specifications

General

Brand	Ford
Model	THUNDERBIRD 1960
Category	Automobile
Language	English