Frigidaire GCCG3048AS User Manual

GAS COOKTOP INSTALLATION INSTRUCTIONS
(For 30" & 36" Models)
INSTALLATION AND SERVICE MUST BE PERFORMED BY A QUALIFIED INSTALLER.
IMPORTANT: SAVE FOR LOCAL ELECTRICAL INSPECTOR'S USE.
READ AND SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.
A01705110 (0921) Rev. A English - pages 1-9
Espagnol - páginas 10-18
Français - pages 19-27
FOR YOUR SAFETY:
— Do not store or use gasoline or other flammable vapors and liquids in
the vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any phone in your building.
• Immediately call your gas supplier from a neighbor's phone.
Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire department.
— Installation and service must be performed by a qualified installer,
service agency or the gas supplier.
All dimensions are stated in inches and (cm).
Dimension H includes a 5" (12,7 cm) space underneath the cooktop for con-
nection to gas supply line.
Figure 1
Gas Cooktop
Cutout Dimensions
Gas Cooktop
Dimensions
CUTOUT DIMENSIONS
F. WIDTH G. DEPTH
H. HEIGHT BELOW
COOKTOP
MODEL MINIMUM MAXIMUM MINIMUM MAXIMUM
30" Gas Cooktop
27 ¼ (69.2 cm ) 29 5/16" (74.3 cm ) 19" (48.3 cm ) 20" (50.8 cm ) 7.5" (19.0 cm)
36" Gas Cooktop 33
7
/
8
" (86.0 cm ) 35 5/8" (90.3) cm 19" (48.3 cm ) 20" (50.8 cm ) 7.5" (19.0 cm)
PRODUCT DIMENSIONS
MODEL A. WIDTH B. DEPTH C. HEIGHT D. BOX WIDTH E. BOX DEPTH
30" Gas Cooktop 30" (76.2 cm) 21" (53.3 cm) 2 7/16" (6.2 cm)
27" (68.6 cm ) 18 7/8" (47.9 cm )
36" Gas Cooktop 36" (91.4 cm) 21" (53.3 cm) 2 7/16" (6.2 cm) 33 5/8" (85.4 cm ) 18 7/8" (47.9 cm )
If the information in this manual is not followed exactly, a fire or explosion may result
causing property damage, personal injury or death.

Frigidaire GCCG3048AS Specifications

General

Brand	Frigidaire
Model	GCCG3048AS
Category	Cooktop
Language	English

Summary

Important Notes to the Installer

Important Note to the Consumer

Special Instructions for Massachusetts

Important Safety Instructions

Cabinet Design Requirements

Typical Under Counter Oven Installation

Installation Over Electric Oven

Wall Outlet Location

Cooktop Installation and Securing

Granite Countertop Installation Kit

Optional kit for granite countertops, orderable via service center or phone.

Clamp Down Procedure

Securing the cooktop in the counter opening using angle brackets and thumb screws.

Gas Supply Requirements

Adequate Gas Supply

Details on operating pressure, regulator, and supply line size for natural gas.

LP/Propane Gas Conversion

Information on conversion kits and requirements for LP/Propane gas.

Pressure Regulator Installation

Gas Connection Assembly

Order of assembly for flexible connector, nipples, unions, and regulator.

Leak Checking and Connections

Procedures for checking gas leaks and ensuring proper connection alignment.

Electrical Requirements

Grounding Instructions

Ensuring the appliance is properly grounded via a 3-prong plug and receptacle.

Power Cord and Grounding

Power Cord Safety

Warning against cutting or bypassing the ground prong.

Burner Cap Placement

Checking Burner Components

Ensuring correct placement of burner caps, heads, and ignitors for proper function.

Ignition and Flame Adjustment

Checking Igniters and Burners

Steps to check igniter sparking and burner ignition, including purging air.

Adjusting Low Flame Setting

Procedure to adjust the minimum flame size for surface burners.

Final Checks and Service

Before You Call for Service

Guidance on using the Use and Care Guide's checklist before contacting service.