Generac Power Systems GTV99O User Manual

SECTION
1: GENERAL INFORMATION
.
Durinq
winter r.onths
30. DO NOT USE SAE
SAE
5W-30, Synthetic
sW-2
0 or 5W'
10w-40.
F
-2A
a 20
40
60
30 rou
c 30
.20 .10
ro
20
30
Temperature
Fange
or Ev€cted
Us6
CHANGE
OIt:
The cra nkcase oil
capacity is
about 2030
ml
(2.
I
qt
)
with the
oilfilter Withoutthe flfter,
the
oilcapacity
is 1750
ml(1.8
qt.).
Use no special additives.
Makesur€
ihatthe
unit
is everwnen
filling
with oil. DO NOT
OVERFILL.
TMPORTANX
DO NOT
OVERF|LL.
Check
and
maintain oil
level
rcgularly.
Change oit
and fittet
aftet
fi6t eight
(8)
houts
of opetation.
Thereafter,
change oil €nd
filter
every t0O
hou6
oJ opera
tion.
Ch:nge
oil more
often il
enqine i5
operated in
dirty or
dusty
conditionsor
f€n9ine
isoperated
und€r healy
|oaos or
high ambient
a ir
temperatures.
Removeoiidrain pllg
and
drain oitwhite
€ngife
is5r wdrin,
Figure
1-2.
Chanqe
o I fllter
(Figure
t-l)and
reptace
dratn
ptuq
figurc
1-1. o
fill Check
Remove
dipnick
and refitlslow y
w
th new
oilof
proper
5€r
vr.e
classification
and viscosity grade.
R€f I
to fu mark
on
dipstick.
When
check ng
oil evet,
d ipst
ck must
be a ll the way
in
for
accurate
readtngs.
Start
and
run
engine
to check for
oil leaks.
CHANGE
O t FLTER:
Replace
oil f lter
€very I
00 hours.
Befo re nstalt
nq
new I rer,
ightly
oil filter
galket
with
fresh
clean engine oit.
Screw fiier
on by hand
until
gasket
cont.cts
filter adapter
Tighten
3/4 to
one
fullturn
fadher, Fiqure
1-3.
Startand run
engineat idle for
30 seconds and
stop engine.
Recheckoi levelandadd
if required.
Reltartengineandcheck
for
oil
leaks.
figure
1-2. OilDrcin
figure 1-3.
Oil Filter
CLIAN NG INTAKT
SCREEN]
Grass
partices,
chaffor
dirt can clog
the atrcooting
system,
especially
after
prolonqed
service ln
cLjtting dry
grass
or v€ry
driry a r.
Continued
operation with
a cogged
cooling
synem
can
cause severe
overheat ng
and
possible
englne
damage.
Fgure
1 4showsth€arcastobecieaned.Thisshoutdbea
reg-
uar marntenance
operation, or
clean ntake scre€n
and ol
cooler
fins after
each use.
1-2

Generac Power Systems GTV99O Specifications

General

Brand	Generac Power Systems
Model	GTV99O
Category	Engine
Language	English