Generac Power Systems PWRcell M3

Owner’s Manual for Generac PWRcell Battery iii
Section 1:Safety Rules & General
Information
Introduction ..........................................................1
Read This Manual Thoroughly ....................................1
Safety Rules .........................................................1
How to Obtain Service ................................................1
General Hazards ..................................................2
Electrical Hazards ................................................3
Battery Hazards ...................................................3
Fire Hazards .........................................................3
Section 2:General Information
PWRcell Battery Naming Convention ................5
Specifications ......................................................6
Serial Number Location ......................................7
Unit Dimensions ..................................................7
Indoor Rated Unit Dimensions ...................................7
Outdoor Rated Unit Dimensions .................................7
Component Locations .........................................8
Accessories ..........................................................8
Touch-Up Paint Kit ......................................................8
Battery Disconnect Switch .................................8
Battery Status LED ..............................................8
About PWRcell Battery ....................................... 8
Communication ................................................... 9
System Operational Modes ................................ 9
Inverter Control Panel ......................................... 9
Battery State of Charge (SoC) Setpoints .......... 9
Battery Settings ................................................. 11
Island Mode ........................................................ 12
Sleep Mode ........................................................ 12
Power Search ..................................................... 12
System Recovery During a Utility Grid
Outage ................................................................ 13
System Blackstart ......................................................14
Section 3:Maintenance
General Upkeep ................................................. 15
Maintenance ....................................................... 15
Inspecting Vents ........................................................15
Cleaning Intake Filter ................................................15
Cleaning Outlet Vent ......................................... 16
Service ................................................................ 16
Decommissioning ............................................. 16
Decommissioning Plan. .............................................16
Battery Recycling ......................................................16
Table of Contents