Generic TR 125 - Troubleshooting; Engine Starting and Running Problems

TROUBLESHOOTING
43
FAILURE Cause To Do
Engine does not start when the electric Battery discharged Charge the battery
starter button is pushed Check the charging of the battery
Check if the generator is working correctly
Fuse is blown Change the fuse
Starter relay defective Check the starter relay
Starter motor defective Check the starter motor
Wrong assembly of roll over sensor Check roll over sensor position
Engine turns but does not start or dies
off A fuse is blown Check the fuses
,GOHVSHHGLVQRWVHWFRUUHFWO\ Adjust the idle speed
Spark plug is contaminated
&OHDQWKHVSDUNSOXJFKHFNWKHHOHFWURGHGLV-
tance
Failure in ignition system Check the ignition system
Wire harness is worn Check the wiring harness
Contact problem in a plug Check the plugs of the wiring harness
1RJDVROLQHLQWKHWDQN 5H¿OOJDVROLQH
Problem with the fuel pump Check the pump
3UREOHPZLWKWKHIXHO¿OWHU &KHFNWKH¿OWHU
Fuel leakage Check the fuel circuit
Engine power is poor $LU¿OWHUFRQWDPLQDWHG &OHDQWKH¿OWHU
)XHO¿OWHUFRQWDPLQDWHG &OHDQWKH¿OWHU
Failure in fuel system Check the fuel system
Problem with the ignition system Check the ignition system
Valve clearance too little Adjust valve clearance
Engine overheats
1RRUQRWHQRXJKFRRODQWLQWKH
system 5H¿OOFRRODQW
Coolant leakage Check the colland circuit
Air in the coolant system Ventilate the system
Thermostat damaged Replace Thermostat