Genius JA382 - 6. START-UP; 6.1. INPUTS CHECK; 7. AUTOMATED SYSTEM TEST

16
ENGLISH
ASSISTANCE REQUEST (combined with next
function):
If activated, at the end of countdown
(settable with the next function i.e. "Cycle
programming") it effects 2 sec. (in addition
to the value already set with the PF function)
of pre-flashing at every Open pulse (job
request). Can be useful for setting
scheduled maintenance jobs.
= Active
= Disabled
Display Function
CYCLE PROGRAMMING:
For setting countdown of system operation
cycles. Settable (in thousands) from
to thousand cycles.
The displayed value is updated as cycles
proceed.
This function can be used to check use of
the board or to exploit the "Assistance
request".
GATE STATUS:
Exit from programming and return to gate
status viewing (see Chpt 5.1.).
6. START-UP
6.1. INPUTS CHECK
The table below shows the status of the LEDs in relation to to the
status of the inputs.
Note the following:
L ED LIGHTED = closed contact
L ED OFF = open contact
Check the status of the LEDs as per Table.
Operation of the signalling status LEDs
NB.: The status of the LEDs while the gate is closed at rest are shown in bold.
7. AUTOMATED SYSTEM TEST
When you have finished programming, check if the system is
operating correctly.
Most important of all, check if the force is adequately adjusted
and if the safety devices are operating correctly.
LEDS LIGHTED OFF
FCA Limit-switch free Limit-switch engaged
FCC Limit-switch free Limit-switch engaged
OPEN B Command activated Command inactive
OPEN A Command activated Command inactive
FSW OP Safety devices disengaged Safety devices engaged
FSW CL Safety devices disengaged Safety devices engaged
STOP Command inactive Command activated
EDGE Safety devices disengaged Safety devices engaged
a/3.baT
"A"CIGOL SESLUP
SUTATSETAGA-NEPOB-NEPOPOTSSECIVEDYTEFASGNINEPOSECIVEDYTEFASGNISOLCECIVEDYTEFAS.SOLC/POE
CIVEDYTEFASEGDE
DESOLC
tisesolcdnafaelehtsnepO
)1(emitesuapretfa
laitrapehtroffaelsnepO
sesolcdnaemitgnine
po
)1(emitesuapretfa
)delbasidNEPO(tceffeoNtceffeoN)delbasidNEPO(tceffeoN
ESUAPnoNEPO )1(emitesuapsdaoleR
no
itarepospotS
tceffeoN )delbasidNEPO()1(emitesuapsdaoleR )delbasidNEPO(tceffeoN
GNISOLCNO )1(yletaidemmifae
lehtsnepo-eR )NEPOsevas(tceffeoN.2.5hpargarapees
,esaelerno,dnaspotS
gnineponosesrever
"2rofgnineponosesre
veR
)2(
GNINEPONO )1(tceffeoN .2.5hpargarapeestceffeoN
,esaelerno,dnaspotS
gnineposeunitnoc
)2("2rofgnisolcno
sesreveR
DEPPOTS faelehtsesolC)delbasidNEPO(tceffeoNtceffeoN )delbasidNEPO(tceffeoN
b/3.baT
"PA"CIGOL SESLUP
SUTATSETAGA-NEPOB-NEPOPOTSSECIVEDYTEFASGNINEPOSECIVEDYTEFASGNISOLCECIVEDYTEFAS.SOLC/P
OECIVEDYTEFASEGDE
DESOLC
tisesolcdnafaelehtsnepO
)1(emitesuapretfa
laitrapehtroffaelsnepO
sesolcdnaemitgnin
epo
)1(emitesuapretfa
)delbasidNEPO(tceffeoNtceffeoN)delbasidNEPO(tceffeoN
ESUAPnoNEPO yletaidemmifaelehtse
solc-eR
noitarepospotS
tceffeoN )delbasidNEPO()1(emitesuapsdaoleR )delbasidNEPO(tceffeoN
GNISOLCNO )1(yleta
idemmifaelehtsnepo-eR )NEPOsevas(tceffeoN.2.5hpargarapees
,esaelerno,dnaspotS
gnineponosesrever
"2rofgnine
ponosesreveR
)2(
GNINEPONO noitarepospotS .2.5hpargarapeestceffeoN
,esaelerno,dnaspotS
gnineposeunitnoc
)2("2
rofgnisolcnosesreveR
DEPPOTS faelehtsesolC)delbasidNEPO(tceffeoNtceffeoN )delbasidNEPO(tceffeoN