gio Royale - Troubleshooting

Troubleshooting
Issue
Possible cause
Solution
No power / no lights
Key switch off
Turn ignition switch ON
Kill switch
Turn kill switch ON
Circuit breaker tripped
Turn circuit breaker ON
Battery not connected
Connect the batteries
Battery not charged
Charge the battery
Ignition switch wires
disconnected
Check wires connection to
ignition set
Wires to circuit breaker
disconnected
Reconnect wires to ignition
switch
Power ON but scooter
doesn’t run
Brakes safety switch is
engaged
Check that brake levers are
released / not applied
Throttle connection
Check throttle wires for
proper connection
Battery not connected
Check and connect both
packs. In some cases the
wire that connects both packs
might be defective.
Battery discharged
Charge battery
Wires to brain module
loosen
Check and reconnect
wires to brain module
Motor wires disconnected
Check and reconnect wires to
the motor
Brain module defective
Replace brain module
Motor defective
Replace motor
Charger not working
No voltage in power outlet
Connect other device in the
same outlet and check for
operation
Charger defective
Replace charger
Battery not charging
Charger not working
Check charger
Battery not connected
Check and connect both
packs. In some cases the
wire that connects both packs
might be defective.
Short running distance
Battery not fully charged
Charge the battery
Brakes not adjusted
Adjust brakes
Battery is old and not
holding a charge
Replace battery
Scooter doesn’t stop when
applying brakes
Brakes not adjusted
Adjust brakes
Brake cable loosen
Place brake cable in proper
position
17