2
Warranty .................................................... 2
Safety Instructions ..................................... 2
Pre-Assembly Instructions..............................4
Hardware, Parts Diagram and Lists ..... 5
Assembly Instructions ................................. 9
Lighting Instructions ............................... 15
Cleaningand Maintenance Instructions .... 17
Frequently Asked Questions .................. 19
Cooking Instructions................................ 20
Grill Chef Warranty
Warranty Restrictions:
• This warranty does not cover surface rust or
natural oxidation.
• This warranty is void if grill is used for commercial
or rental purposes.
• This warranty applies only when the grill is used
in Canada.
• This warranty gives you specific legal rights, and
you may also have other rights which vary from
province to province. See back cover for warranty
details.
Full 1-Year Warranty on Grill
For one year from the date of purchase, the Manufacturer
will repair or replace, at their option, any grill part (except
for paint loss, rusting, AA batteries) that is defective
in material or workmanship.
Limited Warranty on Selected Grill Parts
From the date of purchase for the designated time
periods stated below, the Manufacturer will replace the
following grill parts if they are defective in material or
workmanship. Some charges may appply for shipping
and handling.
• Lifetime of the grill: Stainless steel parts
(except for discoloration due to normal use or
excessive heat, and scratches or dents caused
by normal use and improper maintenance).
Aluminum Castings (except for paint loss)
• 5 Years: Cast-iron Burners
• For Warranty Service: Call our Customer Service
Dept. 8:00am - 5:00pm EST, Monday through
Friday at 1-800-667-7313
Table of Contents
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, immediately call your gas
supplier or your fire department.
If you smell gas:
FOR YOUR SAFETY
Read These Safety Instructions
Grill Installation Codes
The installation must conform with local codes or
in the absence of local codes, with either the
National Fuel Gas Code, ANSI Z223.1/NFPA 54,
or CAN/CGA-B149.1, Natural Gas and Propane
Installation Code.
Correct LP Gas Tank Use
LP gas grill models are designed for use with
a standard 20 lb. Liquid Propane Gas (LP gas)
tank, not included with grill box. Never connect
your gas grill to an LP gas tank that exceeds
this capacity. A tank of approximately 12 inches
in diameter by 18-1/2 inches high is the maxi-
mum size LP gas tank to use. You must use
an "OPD" gas tank which offers a listed
Overfill Prevention Device. Thissafetyfeature
prevents the tank from being overfilled which can
cause malfunction of the LP gas tank, Regulator
and/or grill.
!
WARNING
Combustion by products produced when using
this product contain chemicals known to the
State of California to cause cancer, birth
defects, or other reproductive harm.
Failure to comply with these instructions could
result in a fire or explosion that could cause
serious bodily injury, death, or property
damage.
!
WARNING
Your grill will get very hot. Never lean over the
cooking area while using your grill. Do not touch
cooking surfaces, grill housing, grill lid or any other
grill parts while the grill is in operation, or until
the grill has cooled after use.
Failure to comply with these instructions may
result in serious bodily injury.
!
WARNING
WARNING
(a) Do not store a spare LPG-gas cylinder
under or near this appliance.
(b) Never fill the cylinder beyond 80 percent full
and
(c) If the information in "(a)" and "(b)" is not
followed exactly, a fire causing death or
serious injury may occur.
!
1.
2.
FOR YOUR SAFETY
Do not store or use gasoline or other flam-
mable vapors and liquids in the vicinity of this
or any other appliance.
An LP gas tank not connected for use shall not be
stored in the vicinity of this or any other appliance.
To Next Page
Loading...
