12
HARDI NAVIGATOR
BEFORE OPERATING SPRAYER
Although the sprayer has had a strong and protective
surface treatment applied to steel parts, bolts, etc. in
the factories, it is recommended to apply a thin layer
of anti-corrosion oil to all metal parts, hoses and
tyres.
Suggested products for protecting your equipment
are HENKEL, SHELL ENSIS or one of the CASTROL
RUSTILLO range, eg DW9011M1.
There are many factors that affect the selection of
protective oils, such as temperature and humidity,
and exposure to UV, salt and chemicals. Your local
distributor of oil products will be able to advise on the
best specific formula for your local conditions.
If this is done before the sprayer is put into operation
for the first time, it will always be easy to clean the
sprayer, avoid chemicals discolouring the protective
coating, and keep the coatings shiny for many years.
This treatment should be carried out every time the
protective film is washed off.
Roadworthiness
When driving on public roads and any other areas
where traffic laws apply, please ensure that the required
signs and lights are fitted and working.
WARNING! Maximum driving speed is the lesser of:
20 km/h less than the posted speed limit; and 40
km/h; and the tyre manufacturers recommended
maximum speed / load.
NOTE! It is always recommended to only move the
sprayer by road with an empty tank.
NOTE! Ensure towing vehicle is suited to total load.
Disconnecting sprayer
Disconnect and park the sprayer for storage only after
thorough cleaning and decontamination. (
Cleaning
P22).
Leave the sprayer connected to the towing vehicle
while cleaning the sprayer (inside and outside).
Before disconnecting the sprayer from the towing
vehicle, make sure the support leg is properly fitted.
Place stop wedges in front of and behind the wheels,
and disconnect all hoses and cables from the tractor.
WARNING! To prevent the sprayer from tipping
over, do not disconnect the sprayer from the
tractor with the boom unfolded.
WARNING! If the sprayer is parked unattended,
avoid unauthorised persons, children and
animals having access to the sprayer.
To Next Page
Loading...
Need help?
General
