TABLE OF CONTENTS
SECTION I: General Information
1-1 Specifications ............................................................... 1
1-2 Heater Component Parts ............................................. 2
SECTION II: Installation of Heater
2-1 Location of Heater ........................................................ 3
2-2 Hull Removal ................................................................ 5
2-3 Set-Up of Grates .......................................................... 6
2-4 Location of Plumbing & Electrical Lines ....................... 7
2-5 Connection of Power to Heater .................................... 8
2-6 Wiring Diagram ............................................................ 9
2-7 Plumbing Instructions ................................................. 10
2-8 Filling the Heater with Water ................................. 11-12
SECTION III: Connection to Central Heating/AC System
3-1 Connection to Central Unit
with existing Blower Coil ....................................... 13-15
SECTION IV: Connection to Hydronic Heating Systems (Baseboard)
4-1 Connection to Hydronic System
with existing 24 Volt Transformer ......................... 18-19
4-2 Typical Diagram for Plumbing Hydronic System ....... 20
SECTION V: Plumbing Options for Domestic Water
5-1 Plate Heat Exchanger for Domestic Water ................ 21
SECTION VI: Heater Operation
6-1 Firing the Heater ........................................................ 22
6-2 Water Temperature ................................................... 22
6-3 Wood Usage .............................................................. 22
6-4 Moisture in the Firebox .............................................. 22
6-5 Improper Burning ....................................................... 23
6-6 Ash Removal ............................................................. 23
SECTION VII: Service Information
7-1 Water Circulation System ......................................... 24
7-2 Temperature Control System .................................... 25
7-3 Preseason Heater Maintenance ................................ 26
7-4 Trouble Shooting Guide ........................................ 27-29
(MODEL H25)
vii
To Next Page
Loading...
