Hayward Aqua Trol AQ-TROL-RJ-CUL User Manual

092443A RevB
Copyright © 2010 Hayward
Operation and Installation
Manual
ELECTROLYTIC CHLORINE GENERATOR
BASIC POOL MAINTENANCE REQUIREMENTS
WEEKLY
MONTHLY
QUARTERLY
Free Chlorine 1.0 - 3.0 ppm
pH 7.2 - 7.6
Raise desired output % to
increase, lower desired output %
to decrease -OR- increase or
decrease pump filtration time.
Too low - add soda ash.
Too high - add muriatic acid
Alkalinity 80 - 120 ppm
Salt 2700 - 3400 ppm Add salt as required to increase.
Add baking soda to increase.
Stabilizer 20 - 30 ppm Add cyanuric acid to increase.
Calcium 125 - 250 ppm Add calcium to increase.
Electrolytic Cell inspect & clean Refer to section in manual.
TEST IDEAL RANGE ADJUSTMENT REQUIRED
Drain and add water to decrease.
A
dd acid as required to decrease.
AQ-TROL-RJ-CUL
620 Division St.
Elizabeth, NJ 07207
Aqua Trol
Above Ground Pool Chlorination
www.haywardnet.com
Canada: 888-238-POOL
®
(if necessary)

Hayward Aqua Trol AQ-TROL-RJ-CUL Specifications

General

Pool Size	Up to 18, 000 gallons
Type	Salt Chlorine Generator
Salt Requirement	2700-3400 ppm
Voltage	120/240 VAC
Plumbing Connection	2 inch

Summary

Pool Maintenance Requirements

Safety and Warranty Information

Important Safety Instructions

Critical safety precautions for using the electrical equipment.

Limited Warranty

Details on the product's warranty coverage and exclusions.

Troubleshooting Common Issues

LED Status Indicators

Operation Overview

Diagnostic Displays

Common Problems and Solutions

Addresses issues like the "Power" LED not illuminating.

Installation and Water Chemistry

Water Chemistry Management

Recommended chemical levels and saturation index calculation.

Installation Procedures

Salt Level and Stabilization

Salt Level Adjustment

Guidance on achieving and maintaining optimal salt concentration.

Cell Servicing and Seasonal Care

Cell Cleaning and Maintenance

Controls and Operation Settings

Main Switch and Output Control

Indicator LEDs and Salt Display

Operational Factors