IBC Technologies SL 80-399 - Default Chapter; Safety Considerations; Specifications

INSTALLATION AND OPERATION INSTRUCTIONS
SL 80-399 MODULATING GAS BOILER
SAFETY CONSIDERATIONS
SPECIFICATIONS
WARNING
If the information in this
manual is not followed
exactly, a re or explosion
may result causing property
damage, personal injury, or
loss of life.
Installation, start-up and servicing of IBC boilers must be done with due
care and attention, and should only be performed by competent, qualied,
licensed and trained heating technicians.
Failure to read and comply with all instructions and applicable National and
local codes may result in hazardous conditions that could result in prop-
erty damage and injury to occupants which in extreme cases might result
in death.
HAZARDS &
PRECAUTIONS
WARNING
Points out a potentially
hazardous situation which
must be avoided to prevent
serious injury or death.
CAUTION
Points out a potentially
hazardous situation which
must be avoided to prevent
possible moderate injury and/
or property damage
NOTE
Points out installation,
maintenance and operation
details that will result in
enhanced efciency, longevity
and proper operation of your
boiler.
DANGER
Points out an immediately
hazardous situation which
must be avoided in order
to prevent serious injury or
death.
Specication SL 80-399
CSA Input (Natural Gas or Propane) - MBH
CSA Input (Natural Gas or Propane) - kW
CSA Output - MBH
CSA Output - kW
80 - 399
23.4 - 117
77 - 382
22.6 - 112
Combustion Efciency (CSA 4.9 - 2010) 95.7%
Minimum gas supply pressure (Natural Gas or Pro-
pane) - inch w.c. 5
Maximum gas supply pressure (Natural Gas or Pro-
pane) - inch w.c. 14
Power use (115Vac/60Hz) @ full re - Watts 345 (less pumps)
Weight (empty) - lbs/Kg 240 / 110
Pressure vessel water content - USG/Litres 7 / 26
Maximum boiler ow rate - USgpm 45
Minimum boiler ow rate - USgpm 20
Maximum operating water pressure* - psig 30
Minimum water pressure - psig 8
Approved installation altitude - ASL 0 - 8,000’
Ambient temperature - Low/High (°F-°C) 34°F(1°C)/122(50)
Max. relative humidity (non-condensing) 90%
Minimum water temp. 34°F / 1.1°C
Maximum water temp. (electronic hi-limit) 185°F / 85°C
Maximum water temp. (mechanical hi-limit) 200°F / 93.3°C
Max. ΔT - supply/return (electronic fence) 35°F
Maximum equivalent vent length - 4”
Each side (Vent & Air Intake))
(Natural Gas or Propane)
Air intake options: either direct vent or indoor supply
150’
Supplied with the boiler - The IBC boiler is shipped with an accessory parts kit
consisting of the following items:
1 x Wall mounting bracket•
1 x Condensate trap assembly •
1 x 30 psig pressure relief valve •
1 x Outdoor temperature sensor•
6x1/4”x21/2”Lagscrews/watwashers•
* boilers are shipped with 30 psig pressure relief valve