IBC Technologies VFC 15-150 User Manual

VFCM 15225 Manual V2.1 – May 2007
IBC
IBC Technologies Inc.
Vancouver, Canada
VFC 15-150 and VFC 45-225 Modulating Gas Boilers
(natural gas or propane)
INSTALLATION AND OPERATING INSTRUCTIONS
If the information in this manual is not followed exactly, a fire or explosion may
result causing property damage, personal injury, or loss of life.
Do not store or use gasoline or other flammable vapours and liquids or other
combustible materials in the vicinity of this or any other appliance.
Should overheating occur or the gas supply fails to shut off, do not turn off or
disconnect the electrical supply to the pump. Instead shut off the gas supply at a
location external to the appliance
WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any phone in your building.
• Immediately call your gas supplier from a nearby phone. Follow the gas
supplier’s instructions.
• If you cannot reach your gas supplier, call the fire department.
• Installation and service must be performed by a qualified installer, service
agency or the gas supplier.

IBC Technologies VFC 15-150 Specifications

General

Category	Boiler
Brand	IBC Technologies
Model	VFC 15-150
Fuel Type	Natural Gas or Propane
Efficiency	95% AFUE
Operating Pressure	30 psi
Heating Capacity	150, 000 BTU/hr

Summary

Installation Guide

Installation Code Requirements

Installation must conform to local and national codes for gas and electrical systems.

Boiler Installation Location

Venting Installation Guidelines

Instructions and requirements for proper boiler venting installation.

Venting System Applications

Vent Material Specifications

Specifications for approved materials for intake and exhaust venting systems.

Vent Pipe Travel Limits

Maximum allowable vent lengths and equivalent lengths for various pipe sizes and fittings.

Condensate Trap Installation

Installation requirements for the condensate trap to manage boiler condensation.

Category IV Venting System

Water Piping Installation

Guidelines and requirements for water piping connections and system design.

Water Piping General Issues

Water Piping Installation Rules

Specific rules and recommendations for water piping installation.

Gas Piping Requirements

Requirements for gas supply piping size, connections, and installation practices.

Electrical Connection Guidelines

Instructions and guidelines for all electrical connections to the boiler.

110V Power Hook-up

Power Quality and Protection

Boiler Systems and Operation

Boiler Control Unit

Description of the boiler's control unit and its management functions.

User Interface Navigation

Control Access Levels

Installer Setup Configuration

Boiler Operational Sequence

Detailed explanation of the boiler's operational cycles and states.

Error Mode Conditions

Conditions that lead to errors and the boiler's response to them.

Other Operating Features

Description of advanced functionalities and features of the boiler's operation.

Outdoor Reset Heating Control

Setup and Load Definition

Procedure for configuring the boiler's loads and system parameters.

Startup and Commissioning

Pre-Startup Checks

Essential checks and preparations required before operating the boiler.

Ignition Safety Shutoff Test

Procedure to test the ignition system's safety shutoff functionality.

Gas Valve Calibration

Instructions for adjusting the gas valve for optimal combustion.

Maintenance and Troubleshooting

Boiler Maintenance Procedures

Routine maintenance tasks to ensure proper boiler operation and longevity.

Annual Boiler Inspection

Annual inspection procedures for the boiler and its components by a technician.

Component Descriptions

Troubleshooting Guide

A guide to diagnosing and resolving common boiler problems.

Troubleshooting Preliminary Checks

Initial steps and checks to perform when troubleshooting the boiler.

Electronic Component Troubleshooting

Control Interface Troubleshooting

Using the boiler's control interface to diagnose and resolve issues.

Detailed System Checks

Diagrams and Schematics

Wiring Diagrams

Schematic diagrams illustrating the boiler's electrical wiring.

Boiler Warranty Information

Warranty Coverage Details

Warranty Exclusions

Warranty Service Procedure

Steps to follow to obtain warranty service for the boiler.