Intertherm BM36HCD - User Manual

NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
1
RETAIN THESE INSTRUCTIONS
FOR FUTURE REFERENCE
WH Report No. J99025865A
36" Wood Burning Fireplaces
P/N 800,019M REV. B 04/2002
BM36HC BM36HCD
MODELS
DELUXE 36
MANUFACTURED HOME
FIREPLACES
This installation manual will enable you to obtain a safe, efficient and
dependable installation of your fireplace system. Please read and under-
stand these instructions before beginning your installation.
Do not alter or modify the fireplace or its components under any
circumstances. Any modification or alteration of the fireplace system,
including but not limited to the fireplace, chimney components and
accessories, may void the warranty, listings and approvals of this system
and could result in an unsafe and potentially dangerous installation.
IMPORTANT! TO ASSURE PROPER ALIGNMENT OF GLASS DOORS:
INSTALL THIS FIREPLACE IN A SQUARE AND PLUMB CONDITION,
USING SHIMS AS NECESSARY AT SIDES AND/OR BOTTOM.
PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE.
INSTALLATION
INSTRUCTIONS

Summary

Introduction and Precautions

Introduction

General information about the fireplace system and its purpose.

Precautions

Essential safety and installation guidance for a secure setup.

Clearances and Height Requirements

Specifies required spacing from combustibles and minimum system height.

Chimney System

Details on the mandatory FireCraft Technologies' FTF8 chimney.

Assembly and Location Planning

Assembly Outline

Overview of the installation process and initial parts check.

Location of Fireplace

Guidance on selecting the optimal site for fireplace installation.

Assembly Steps

Step-by-step instructions for assembling the fireplace unit.

Core Installation Procedures

Pre-installation Notes

Critical considerations and checks before starting installation.

Clearances

Detailed minimum clearance requirements to combustible materials.

Installing the Fireplace

Steps for positioning and securing the fireplace unit within the structure.

Fireplace Technical Specifications

Fireplace Specifications

Technical dimensions, clearances, and key features of the fireplace.

Framing and Structural Requirements

Framing Specifications

Dimensions and instructions for framing the fireplace enclosure.

Chimney System Installation Guide

Installing the Chimney System

Procedures for routing, securing, and sealing the chimney.

Chimney Height Requirements

Details on minimum and maximum chimney heights and system configuration.

Chimney Components and Offset Assembly

Chimney Sections and Stabilizers

Guidelines for assembling chimney sections and using stabilizers.

Chimney Termination and Height Rules

Chimney Termination (FBTM)

Steps for correctly installing the FBTM termination cap.

Ten Foot Rule Summary

Guidelines for chimney height relative to roof peaks and adjacent structures.

Chimney Calculations and Offset Planning

FT8 Chimney Component Calculations

Determining the necessary chimney parts and lengths for installation.

Special Offset Instructions

Guidance for 30° chimney offsets through floors and ceilings.

Offset Calculations

Using charts to determine horizontal and vertical offset dimensions.

Vertical Chimney Height Calculations

FT8 Vertical Elevation Chart

A comprehensive table for calculating vertical chimney heights.

Offset Chimney Dimension Calculations

FT8 Offset Elevation Chart

A table for determining dimensions for offset chimney runs.

Offset Installation and Optional Upgrades

Installing Offsets

Detailed step-by-step guide for installing angled chimney sections.

Optional Equipment Considerations

Information on installing optional upgrades like the blower kit.

Air Intake and Gas Line Setup

Combustion Air Kits

Installation procedures for the outside combustion air intake system.

Gas Line Connection

Steps and precautions for connecting gas lines to the fireplace.

Cold Climate Insulation

Recommendations for insulating the fireplace in cold environments.

Fireplace Finishing and Protection

Glass Doors

Instructions for adjusting and installing the fireplace glass doors.

Mantels and Trim

Guidelines for installing decorative mantels and trim around the fireplace.

Hearth Extensions and Wall Shields

Requirements for floor protection and wall shielding.

Hearth Extension Material Calculations

Hearth Extension and Wall Shield Equivalents

Methods for calculating material thickness based on thermal resistance.

Aesthetic Finishing and Component Listing

Finish to Your Taste

Guidance on various aesthetic finishing options for the fireplace.

Installation Components

A list of available parts and accessories for installation.

Intertherm BM36HCD Specifications

General

Brand	Intertherm
Model	BM36HCD
Category	Indoor Fireplace
Language	English