7-7
3. Open the main valve slowly to avoid a fast rush of propane to the excess flow
valve causing propane freeze up. If you experience a propane “freeze-up,”
close the main valve and wait at least fifteen (15) minutes before trying again.
Refer to the regulator manufacturer’s operator manual.
4. Listen carefully - a “hissing” sound longer than one second may indicate a
propane leak. If you feel there may be a leak present, close the valve and
contact your dealer or qualified propane technician for repair assistance.
Replace all protective covers and caps on the propane system after filling. Make
sure the valve is closed and the compartment door is securely latched.
Maintenance
Propane gas is normally non-corrosive - you need not worry about the inside of
your container. However, the outside should be kept free from rust by a periodic
coat of paint in a light reflective color. Rust, scratches and/or dents can affect the
safety of the cylinder. Inspect the cylinder at regular intervals.
If there is a problem, have it evaluated by a qualified technician and discard it.
DOT requires that a visual inspection be made prior to each filling.
Any cylinder that has been exposed to fire, leaks or seems damaged should not
be refilled.
Do not attempt to repair any containers, container valves, regulator or appliances
by yourself. Use only trained certified propane gas service technicians to perform
repairs.
Propane cylinder recertification
If you have an older RV you should know that, according to Federal law, DOT
cylinders may only be used for 12 years after their manufacture date (the number
of years for certification may vary in your area). After that, the cylinders must be
"recertified" which provides another five years of use.
The cylinders can be recertified every five years thereafter. Federal DOT
(Department of Transportation) regulations require periodic inspections and re-
qualifications of the propane cylinders. DO NOT USE damaged or rusted
containers.
Verify with your local propane dealer that all required inspections and certifications
have been completed on the propane cylinder within the correct time period before
refilling the cylinder.
Have the LP system checked for leakage each time a cylinder is refilled or after
any part of the propane system has been disconnected.
PROPANE REGULATOR
Single stage regulator
Some models are equipped with a single stage regulator.
To Next Page
Loading...
Need help?
General
