JUKI DDL-8700B-7 Cautions For Safety

iv
iv
5. Besuretoturnthepoweroffandchecktobesurethatthemachineandmotorcompletelystopbeforere-
movingthebeltcoverandV-beltinordertopreventaccidentcausedbyabruptstartofthemachineormotor.
 6. Ifaservomotorisusedwiththemachine,themotordoesnotproducenoisewhilethemachineisatrest.
Besurenottoforgettoturnthepoweroffinordertopreventaccidentcausedbyabruptstartofthemotor.
 7. Neverusethemachinewiththecoolingopeningofthemotorpowerboxshieldedinordertopreventre
accidentbyoverheat.
Lubrication
 1. BesuretouseJUKIgenuineoilandJUKIgenuinegreasetothepartstobelubricated.
 2. Iftheoiladheresonyoureyeorbody,besuretoimmediatelywashitoffinordertopreventinamma-
tionorirritation.
 3. Iftheoilisswallowedunintentionally,besuretoimmediatelyconsultamedicaldoctorinordertopre-
ventdiarrheaorvomiting.
Maintenance
 1. Inpreventionofaccidentcausedbyunfamiliaritywiththemachine,repairandadjustmenthastobe
carriedoutbyaservicetechnicianwhoisthoroughlyfamiliarwiththemachinewithinthescopedened
intheinstructionmanual.BesuretouseJUKIgenuinepartswhenreplacinganyofthemachineparts.
JUKIassumesnoresponsibilityforanyaccidentcausedbyimproperrepairoradjustmentortheuseof
anypartotherthanJUKIgenuineone.
 2. Inpreventionofaccidentcausedbyunfamiliaritywiththemachineorelectrical-shockaccident,besure
toaskanelectricaltechnicianofyourcompanyorJUKIordistributorinyourareaforrepairandmainte-
nance(includingwiring)ofelectricalcomponents.
 3. Whencarryingoutrepairormaintenanceofthemachinewhichusesair-drivenpartssuchasanaircyl-
inder,besuretoremovetheairsupplypipetoexpelairremaininginthemachinebeforehand,inorderto
preventaccidentcausedbyabruptstartoftheair-drivenparts.
 4. Besuretocheckthatscrewsandnutsarefreefromloosenessaftercompletionofrepair,adjustment
andpartreplacement.
 5. Besuretoperiodicallycleanupthemachineduringitsdurationofuse.Besuretoturnthe
poweroff
and
verifythatthemachineandmotorstopcompletelybeforecleaningthemachineinordertoprevent
accidentcausedbyabruptstartofthemachineormotor.
 6. Besuretoturnthepoweroffandverifythatthemachineandmotorstopcompletelybeforecarryingout
maintenance,inspectionorrepairofthemachine.(Forthemachinewithaclutchmotor,themotorwill
keeprunningforawhilebyinertiaevenafterturningthepoweroff.So,becareful.)
 7. Ifthemachinecannotbenormallyoperatedafterrepairoradjustment,immediatelystopoperationand
contactJUKIorthedistributorinyourareaforrepairinordertopreventaccidentthatcanresultinper-
sonalinjuryordeath.
 8. Ifthefusehasblown,besuretoturnthepoweroffandeliminatethecauseofblowingofthefuseand
replacetheblownfusewithanewoneinordertopreventaccidentthatcanresultinpersonalinjuryor
death.
 9. Besuretoperiodicallycleanuptheairventofthefanandinspecttheareaaroundthewiringinorderto
preventreaccidentofthemotor.
Operatingenvironment
 1. Besuretousethemachineundertheenvironmentwhichisnotaffectedbystrongnoisesource(electro-
magneticwaves)suchasahigh-frequencywelderinordertopreventaccidentcausedbymalfunctionof
themachine.
 2. Neveroperatethemachineinanyplacewherethevoltageuctuatesbymorethan"ratedvoltage±10%"
inordertopreventaccidentcausedbymalfunctionofthemachine.
 3. Besuretoverifythattheair-drivendevicesuchasanaircylinderoperatesatthespeciedairpressure
beforeusingitinordertopreventaccidentcausedbymalfunctionofthemachine.
 4. Tousethemachinewithsafety,besuretouseitundertheenvironmentwhichsatisesthefollowing
conditions:
  Ambienttemperatureduringoperation 5°Cto35°C
  Relativehumidityduringoperation 35%to85%
 5. Dewcondensationcanoccurifbringingthemachinesuddenlyfromacoldenvironmenttoawarmone.
So,besuretoturnthepoweronafterhavingwaitedforasufcientperiodoftimeuntilthereisnosign
ofwaterdropletinordertopreventaccidentcausedbybreakageormalfunctionoftheelectricalcompo-
nents.
 6. Besuretostopoperationwhenlightningashesforthesakeofsafetyandremovethe
powerplugin
order
topreventaccidentcausedbybreakageormalfunctionoftheelectricalcomponents.
 7. Dependingontheradiowavesignalcondition,themachinemaygeneratenoiseintheTVorradio.Ifthis
occurs,usetheTVorradiowithkeptwellawayfromthemachine.
 8. Inordertoensuretheworkenvironment,locallawsandregulationsinthecountrywherethesewing
machineisinstalledshallbefollowed.
Inthecasethenoisecontrolisnecessary,anearprotectororotherprotectivegearshouldbewornac-
cordingtotheapplicablelawsandregulations.
 9. Disposalofproductsandpackagesandtreatmentofusedlubricatingoilshouldbecarriedoutproperly
accordingtotherelevantlawsofthecountryinwhichthesewingmachineisused.

JUKI DDL-8700B-7 Specifications

General

Brand	JUKI
Model	DDL-8700B-7
Category	Sewing Machine
Language	English