Kohler 12RES Operation And Installation

Table of Contents, continued
TP-6195 1/04Table of Contents
Section 4 Troubleshooting 19.................................................................
4.1 Introduction 19..........................................................
4.2 Generator Set Troubleshooting 19..........................................
4.3 Fault Codes 20..........................................................
4.4 Controller Troubleshooting 20.............................................
4.5 Battery Charger Troubleshooting 20........................................
Section 5 Wiring Diagrams 21................................................................
5.1 Specification Numbers 21.................................................
5.2 Controller Wiring Diagram Reference 21....................................
Section 6 Installation 25......................................................................
6.1 General 25..............................................................
6.2 Weight 25...............................................................
6.3 Generator Set Inspection 25...............................................
6.4 Mounting 25.............................................................
6.5 Exhaust Requirements 25.................................................
6.6 Air Requirements 27.....................................................
6.7 Power Supply 27.........................................................
6.8 Fuel System 27..........................................................
6.8.1 Fuel Supply 27..................................................
6.8.2 Fuel Pipe Size 28................................................
6.8.3 Fuel Conversion 28..............................................
6.9 Electrical Connections 31.................................................
6.9.1 AC Load Lead Connections 31.....................................
6.9.2 Remote Start Connection (optional) 32..............................
6.9.3 Continuous Power Mode Jumper 32................................
6.9.4 Battery 33.......................................................
6.9.5 Battery Charger 34...............................................
6.10 Accessories 35..........................................................
6.10.1 Common Fault and Run Relay Board 35............................
6.10.2 Carburetor Heater 36.............................................
6.11 Controller Configuration 37................................................
6.11.1 System Configuration 37..........................................
6.11.2 Advanced Configuration Mode 37..................................
6.12 Prestart Installation Check 37..............................................
6.13 Warranty Registration 37..................................................
Appendix A Abbreviations A-1..................................................................

Kohler 12RES Specifications

General

Voltage	120/240 V
Frequency	60 Hz
Power Output	12, 000 watts
Phase	Single
Starting System	Automatic
Transfer Switch	Optional