Kohler Command PRO CH270 - Maintenance Instructions; Maintenance Schedule; Checking Engine Oil Level

11
Frequency Maintenance Required
Daily or
Before Starting Engine
Check oil level.
Fill fuel tank.
Check air intake and cooling areas; clean as necessary.¹
Check air cleaner and precleaner.
&KHFNPXIÀHUVFUHHQLIHTXLSSHGFOHDQDVQHFHVVDU\ï
Yearly or Every 50 Hours Clean or replace precleaner.
Yearly or Every 100 Hours
Change oil.
Clean cooling areas.
&OHDQPXIÀHUVFUHHQLIHTXLSSHG
Clean, set gap or replace spark plug, and set gap.
Yearly or Every 200 Hours
Replace air cleaner element.
5HSODFHIXHO¿OWHULIHTXLSSHG
Yearly or Every 200 Hours
Check and adjust valve clearance when engine is cold.
2
Service starter motor drive, if so equipped.
2
Have combustion chamber decarbonized.
2
¹Perform these maintenance procedures more frequently under extremely dusty, dirty conditions.
²Have a Kohler Engine Service Center perform this service.
Check Oil Level
ȱȱȱȱȱȱȱȱ
ȱȱȱȱȱȱȱ£ǯȱ
ȱȱȱȱȱȱDZ
ȱ ŗǯȱ ȱȱȱȱȱǰȱǰȱȱȱȱ
ȱȱȱȱȱȱȱȱȱȱǯ
ȱ Řǯȱ ȱȱȱȱȱȱȱȱȱ
ȱȱęȱȱȱȱǯȱȱȱȱ
ȱǰȱǰȱȱȱȱĴȱȱȱ
ȱǯȱȱȱŗŜǯ
DZȱȱȱ¢ȱȱȱȱȱȱ
ȱȱȱęȱȱȱȱǯȱȱȱȱ
ȱȱȱǯȱȱȱŗŜǯ
Figure 16. Location of Dipstick and Oil Fill Plug.
Oil Fill
Plug
Oil Drain Plug
Dipstick
Oil Drain Plug
Maintenance Instructions
ǰȱȱȱȱȱȱȱȱȱȱ¢ǰȱȱȱȱȱȱȱ
ȱ¡ǰȱ¢ȱȱȱ¢ȱ¢ȱȬȱȱȱȱȱǯȱ¢ȱ
ȱȱȱȱ¢ȱȱ£ȱȱȱȱǯ
WARNING
ȱȱȱȱȱ
¢ȱȱǯ
ȱȱȱȱȱ
ȱȱǯ
ȱǯȱȱȱȱȱȱ¢ȱȱǯȱȱȱȱȱȱȱǰȱȱȱ
ȱȱDZȱŗǼȱȱȱȱȱǻǼǯȱŘǼȱȱȱǻȬǼȱĴ¢ȱȱȱĴ¢ǯ
Maintenance Schedule
ȱȱȱȱȱȱȱȱȱ¢ȱȱȱȱȱǯȱ¢ȱ
ȱȱȱȱȱȱȱ¢ȱȱȬǯ