LABEL-AIRE Write-up 3138NV-DAT - LOW LABEL DETECTOR

28

Asanoption,theapplicatorcanbeequippedtoeithermonitortheEndofWeb,orWebBreak,
butnotboth.Thisdetectorrequiresnoset‐upandismountedadjacenttothewebpath.When
thedetectordetectstheabsenceoftheweb,thealarmoccurs.
ThesinglestandardalarmlightwillalsoblinkslowlyiftheprinterpowerswitchisOFF(0)
wheneverthemainpowerswitchisON(I),andthemachineisONLINE.Thesinglestandard
alarmlightwillstopblinkingwhentheprinterpowerswitchisturnedON(I)andthenthe
machineisplaced0FFLINEandthenbackONLINE.
The[ESC]buttonservesastheresetswitchfortheLowLabel,LowRibbon,EndofWeb,and
WebBreakalarms.
 LOW LABEL DETECTOR
Thelowlabeldetectorisaphotoelectricsensorwhichtriggersthealarmlightwhenthesupply
oflabelsisalmostexhausted.UsethefollowingproceduretocheckthefunctionoftheLow
LabelDetector.

1.PlacethemachineONLINE.
 NOTE:ThealarmlightwillnotfunctionwiththemachineOFFLINE.
2.Pushthedancerarmtowardtheprinterandrotatetheunwindrolloflabelsuntiltheslotin
theinnerunwinddiskisdirectlyinfrontofthelowlabeldetector.
3.Remove
theouterunwinddiskandslidethefullrolloflabelsawayfromtheinnerunwind
disk.
4.Ifthelowlabelalarmdetectorsensitivityisproperlyset,thealarmlightwillactivate.
5.Ifthealarmlightisfunctioning,replacethelabelsontheunwindandgoontotheLowLabel
AlarmTriggerPoint.
Ifthealarmlightisnotfunctioningproperly,goontotheLOWLABELSENSITIVITYSECTION.
