Legend Pontoon Series User Manual

22
LUBRICATING SYSTEM:
Complete Oil Injection System including: Oil Injection Check Valve, Injection Pump, Pump Drive Gear,
Pump Drive Shaft, Low Oil Level Sensor, Oil Flow Warning Sensors and Control Modules, Oil Tank Reservoir,
Tank (Oil) Cap, Tank Pickup Tube, Oil Level Warning Horn and/or Light, Oil Lines, Complete Metering
System. Warning Module, Remote Injection Tank, Seals and Gaskets in conjunction with a failure of a listed
component only.
JET DRIVE:
All internal lubricated parts contained within the Pump Housing, Seals and Gaskets in conjunction with a
failure of a listed component only. NOTE: Pump Housing is covered only if damaged by the failure of an
internally lubricated part.
POWER TRIM AND TILT:
Spring, Sending Unit, Oil Pump, Pump Relief Valve, O-Ring, Trim Cylinder, Tilt Cylinder, Hydraulic Pump,
Manual Release Valve, Reverse Lock Valve, Solenoids, Power Tilt Motor and Power Trim Motor, Seals and
Gaskets in conjunction with a failure of a listed component only.
FUEL SYSTEM:
Fuel Delivery Pump, Fuel Injection Pump, Fuel Injector(s), Fuel Distributors, Flame Arrester, Rails, Fuel Tank,
Metal Fuel Lines and Fittings, Fuel Pressure Regulator, Wiring Harness, Seals and Gaskets in conjunction with
a failure of a listed component only.
ELECTRICAL:
Alternator, Rectier, Voltage Regulator, Starter Motor, Starter Solenoid, Starter Drive, Engine Mounted Wiring
Harness and Connectors, Windshield Wiper Motor, Power Pack / Switch Box, Distributor, Ignition Coil and
Switch, Engine Control Module, Electronic Ignition Module / CDI, ECU/Electronic Fuel Injection Control
Modules / Sensors, Limit and Control Switches, Trigger Coil and Stator, Stereo (Factory or Dealer Installed
Audio System – Speakers are Excluded).
STEERING:
Steering Control Helm Assembly, Steering Bracket and Bushing, Swivel Bracket and Bearing, Control Rack
and Yoke Assembly, Power Steering Pump, Power Cylinder Assembly, Steering Wheel and Coupling, Hub and
Steering Cables, Seals and Gaskets in conjunction with a failure of a listed component only.
CONTROLS:
Throttle Assembly, Remote Control Starter/Choke Primer Switch, Starter/Stop Switch, Trim/Tilt Switch
and Ignition Switch, Shift & Throttle Cables, Shift Control Box, Shift Interrupter Switch. Turbocharger /
Supercharger (factory installed only) Turbocharger / Supercharger Housing (when damaged from within)
and all internal lubricated parts including Turbine(s), Shaft, Bushings and Waste Gate Actuator, Seals and
Gaskets in conjunction with a failure of a listed component only.
SPORTSPLUS Package
Electric Trolling Motor: All internal parts contained within the Motor Housing, Wiring Harness, Foot/
Hand Speed Control, Steering Cable and Gears, Bow Arm Bracket, Seals and Gaskets in conjunction with a
failure of a listed component only. Depth Finder/Fish Finder: Unit, Wire Harness, Control Cable, Transducer.
Electrical Accessories: Bilge Pump, Bilge Blower, Live Well Pump, Aerier, Sea/Lake Water Temperature Gauge
including Sensor and Control Cable, PH Meter, Battery Main Switch and Selector Switch, Isolator Switch, Tach
Head, Voltage and All Pressure Gauges, Fuel Gauge, Speedometer and Tilt/Trim Gauge, Remote Spotlight
(manual control panel, horizontal/vertical control motors, light housing), Bow and Marker Lights, Running
Lights, Cockpit Lights,. Electric Horn, Stereo: Factory or Dealer Installed Audio System. NOTE: Speakers are
Excluded). Anchor / Control System: Winch, Electric Windless Motor, Bow Pulpit Guide, and Switches. System
Monitors: Fume detector Carbon Monoxide (CO), Fuel Vapour, and High Bilge Level Sensor. Canvas Top: All
Mechanical Components of Canvas Top System.
TRAILER Package
Master Cylinder, Hydraulic Brake Actuator, Backing Plates, Trailer Frame Welds, Suspension Springs, Spring
Hanger Brackets and U-Bolts, Axles, Spindles, Wheel Bearings, Hubs, Roller Cradles (excluding Rollers),
Manual Winch and Stand, Seals and Gaskets in conjunction with a failure of a listed component only.
If you have any questions after reading this manual, please feel free to contact your
local Legend dealer or call 1.800.461.4050
Thank you for choosing Legend!!

Legend Pontoon Series Specifications

General

Engine	Outboard
Category	Pontoon Boat
Tube Diameter	25 inches
Max Capacity	Varies by model (refer to specific model specs)
Motor Capacity	Varies by model (refer to specific model specs)