Leviton Black & white - User Manual

Plugs and Connectors
15A - 20A Straight Blade, and Locking
NEMA & NON-NEMA
IP20 Suitability
WIRING INSTRUCTIONS
ENGLISH
WARNINGS AND CAUTIONS:
s 4OBEINSTALLEDANDORUSEDINACCORDANCEWITHAPPROPRIATEELECTRICALCODESANDREGULATIONS
s )FYOUARENOTSUREABOUTANYPARTOFTHESEINSTRUCTIONSCONSULTANELECTRICIAN
s 5SETHISDEVICEWITHstranded copper wire only
s Non-grounded devices are for connection to non-grounded circuits only.
s Non-NEMA devices are UL Listed for replacement use only.
TO INSTALL
b
l
ac
k
&
whi
te
NOTE: 7)2%3):%!.$490%-534#/-0,97)4(!002/02)!4%,/#!,%,%#42)#!,#/$%3).53!2%&%24/.%#4!",%3!24)#,%
WARNING:4/!6/)$&)2%3(/#+/2$%!4(UNPLUG CORD OR TURN OFF POWER!4#)2#5)4"2%!+%2/2&53%!.$4%344(!40/7%2)3/&&"%&/2%7)2).'
1. 3ELECTSIZEANDTYPEOFROUNDCORDASPERYOURREQUIREMENTS
2. ,OOSENASSEMBLYSCREWSANDSEPARATEDEVICEBODYFROMHOUSING
3. $ETERMINEIFCABLEISLARGERTHAN'!'%ONTHEBACKOFHOUSING"ACKOUTCLAMPSCREWSTOREMOVESTRAINRELIEFINSERTIFREQUIRED4HEDEVICESTRAINRELIEFWILLACCOMODATECORDS
FROMTOWITHSTRAINRELIEFINSERTINSTALLEDANDFROMTOWITHSTRAINRELIEFINSERTREMOVEDASPERCABLEGAGEONHOUSING(see Table 1)
4 &EEDWIRINGCORDTHROUGHHOUSING
5. 3TRIPCORDJACKETCM3TRIPEACHCONDUCTORINSULATIONCMASPERFig. 1.ORASPERSTRIP'!'%MOLDEDONTHEBACKOFWIRINGCOVER
6. Connect wires:#AREFULLYBACKOUTALLTERMINALWIRINGSCREWSUNTILEDGEOFBACKWIRECLAMPISNOTVISIBLEINWIREWELL4WISTTHESTRANDSOFEACHSTRIPPEDCONDUCTORTIGHTLYTOGETHER
ANDINSERTINTOPROPERWIREWELL(see Table 2)4IGHTENWIRINGSCREWlRMLYTOIN)BSTORQUECHECK FOR STRAY WIRE STRANDSRepeat for all conductors
NOTE:7HEREAPPLICABLEITISRECOMMENDEDTOCONNECT'2/5.$WIRElRST
CAUTION: Wiring clamps MUST contact on conductor only, NOT on insulationDO NOT USE SOLID WIRE. DO NOT TIN CONDUCTORS
7. 2EATTACHTHEWIREDMODULETOTHEHOUSINGBYALIGNINGKEYGUIDEONTHEMODULETOTHEKEYONTHEHOUSINGANDTIGHTENTHEASSEMBLYSCREWSlRMLYTOIN)BSTORQUE
&IRMLYSECURECORDCLAMPONTOHOUSINGBYALTERNATELYTIGHTENINGCORDCLAMPSCREWSTOINLBSTORQUE
NOTE: Polarity of wiring for NEMA devicesISIDENTIlEDBYMARKINGSONDEVICEANDORSCREWCOLORASSHOWNBELOW
0OLARITYOFWIRINGFOR./..%-!DEVICESREFERTOEXISTINGINSTALLATION
For Technical Assistance Call: 1-800-824-3005 (U.S.A. Only) www.leviton.com
LIMITED LIFETIME WARRANTY AND EXCLUSIONS
,EVITONWARRANTSTOTHEORIGINALCONSUMERPURCHASERANDNOTFORTHEBENElTOFANYONEELSETHATTHISPRODUCTATTHETIMEOFITSSALEBY,EVITONISFREEOFDEFECTSINMATERIALSANDWORKMANSHIPUNDERNORMALANDPROPERUSEDURING
THELIFETIMEOFTHEPRODUCT,EVITONSONLYOBLIGATIONISTOCORRECTSUCHDEFECTSBYREPAIRORREPLACEMENTATITSOPTIONIFTHEPRODUCTISRETURNEDPREPAIDWITHPROOFOFPURCHASEDATEANDADESCRIPTIONOFTHEPROBLEMTOLeviton Mfg.
Co., Inc. 201 North Service Road, Melville, N.Y. 11747.4HISWARRANTYEXCLUDESANDTHEREISDISCLAIMEDLIABILITYFORLABORFORREMOVALOF THIS PRODUCT OR REINSTALLATION4HISWARRANTYIS VOIDIFTHISPRODUCTISINSTALLEDIMPROPERLY
OR IN AN IMPROPER ENVIRONMENTOVERLOADED MISUSED OPENED ABUSED OR ALTERED IN ANYMANNEROR IS NOT USED UNDER NORMAL OPERATING CONDITIONS OR NOT IN ACCORDANCE WITH ANY LABELS OR INSTRUCTIONS4HERE ARE NO OTHER OR
IMPLIED WARRANTIES OF ANY KIND INCLUDING MERCHANTABILITY AND lTNESS FOR A PARTICULAR PURPOSE ,EVITON IS NOT LIABLE FOR INCIDENTAL INDIRECT SPECIAL OR CONSEQUENTIAL DAMAGES INCLUDING WITHOUT LIMITATION DAMAGE TO OR LOSS OF
USE OF ANY EQUIPMENT LOST SALES OR PROlTS OR DELAYOR FAILURE TO PERFORM THIS WARRANTY OBLIGATION4HE REMEDIES PROVIDEDHEREIN ARE THE EXCLUSIVE REMEDIES UNDER THIS WARRANTY WHETHER BASED ON CONTRACT TORT OR OTHERWISE
0+#
Fig. 1
15/16"
(2.38 cm)
9/16"
(1.43 cm)
Cord Jacket
Gaine
Forro del Cordón
Insulation
Isolant
Aislante
Copper Strands
Brins de cuivre
Hilos de cobre
3/8"
(.95 cm)
MARKING ON NEMA DEVICE
-!215%3352,%3$)30/3)4)&3.%-!
MARCAS EN EL PRODUCTO NEMA
G, GRND, GREEN, or EQ GR
''2.$'2%%.OU%1'2
G, GRND, GREEN, o EQ GR
W, OR WHITE
7OU",!.#
W, o BLANCO
X,Y,Z or BLANK
89:OU2)%.
X,Y,Z o BLANK
CONDUCTOR COLOR
#/5,%523$%3#/.$5#4%523
COLOR DEL CONDUCTOR
Bare, Green, or Green/Yellow wire
$£NUD£VERTOUVERTJAUNE
Conductor Pelado, Verde, o Verde/Amarillo
White or Gray wire
"LANCOUGRIS
Conductor Blanco o Gris
Black, Red, Blue or any other than White, Green, Gray, Green/Yellow or Bare wire
.OIRROUGEBLEUOUTOUTEAUTREQUEBLANCVERTGRISVERTJAUNEOUD£NUD£
Conductor Negro, Rojo, Azul o cualquier otro que Blanco, Verde, Gris, Verde/Amarillo o Pelado
NEMA SCREW COLOR
#/5,%523$%36)3.%-!
COLOR DEL TORNILLO NEMA
(Grounding) -- GREEN
4
ERRE6%24
(a Tierra) - VERDE
(Neutral) -- SILVER
.EUTRE!2'%.4
(Neutro) -- PLATEADO
(Hot) -- BRASS or BLACK
!CTIF,!)4/.OU./)2
(Fase) -- LATON o NEGRO
RATING & TERMINAL SCREW COLOR
6!,%523./-).!,%3%4#/5,%523$%3"/2.%3
COLOR DEL TORNILLO TERMINAL Y CAPACIDAD
Wires
&ILS
Conductores
Gr
ound
4ERRE
a Tierra
Hot
!CTIF
Fase
Hot
!CTIF
Fase
Hot
!CTIF
Fase
125V/250V
6
125/250V
NON NEMA for
replacement
only
.ONNEMAPOURLESREMPLACEMENTSSEULEMENT
Solo para reemplazo NO NEMA
250V3Ø
6
250V3Ø
------
------
Brass/Black
,AITONNOIR
Latón/Negro
Brass/Black
,AITONNOIR
Latón/Negro
Brass/Black
,AITONNOIR
Latón/Negro
,
250V Non-Grounding
6SANS-!,4
250V sin conexión
a tierra
------
------
------
Brass/Black
,AITONNOIR
Latón/Negro
Brass/Black
,AITONNOIR
Latón/Negro
,
Neutral
.EUTRE
Neutro
Configurations
#ONlGURATIONS
Configuraciones
125V Non-Grounding
16SANS-!,4
125V sin conexión
a tierra
------
------
------
Brass/Black
,AITONNOIR
Latón/Negro
,

Silver
!RGENT£
Plateado
125V or 277V and 347V GR
OUET6-!,4
125 o 277 y 347V T
------
------
Green
6ER T
Verde
Brass/Black
,AITONNOIR
Latón/Negro
Silver
!RGENT£
Plateado
,
,





250V GR
6-!,4
250 T
------
------
Green
6ER T
Verde
Brass/Black
,AITONNOIR
Latón/Negro
Brass/Black
,AITONNOIR
Latón/Negro
,


Table 2 / 4ABLEAU Tabla 2Table 1 / 4ABLEAU Tabla 1
APPROXIMATE CORD DIAMETERS
$)!-¥42%!002/8)-!4)&$%3#/2$/.3
DIAMETRO APROXIMADO DE CORDON
33/
34

34/
Type
4YPE
Tipo
AWG Size
#ALIBRE!7'
Tamaño AWG
2 Conductor
#ONDUCTEURS
2 Conductores
3 Conductor
#ONDUCTEURS
3 Conductores
  
  
  
  
  
364
  
WEB VERSION

Summary

WIRING INSTRUCTIONS

WARNINGS AND CAUTIONS

Important safety warnings and installation guidelines to follow.

TO INSTALL

Step-by-step guide for wiring plugs and connectors, including wire preparation.

LIMITED LIFETIME WARRANTY AND EXCLUSIONS

Leviton Black & white Specifications

General

Brand	Leviton
Model	Black & white
Category	Cables and connectors
Language	English