10
6 MAINTENANCE
Controller and Pump
The controllers electronic has no moving or
wearing parts. It requires no maintenance.
There are rubber plugs to seal at the bottom,
unused conduit holes. Inspect them to insure
that the controller is sealed from moisture,
insects, etc. Check that mounting and conduit
hardware is tight.
Motor The motor requires no maintenance.
It has no brushes or other frequently wearing
parts.
Pump end The pump mechanism (pump
end) is lubricated only by water and requires
no maintenance. It may wear after some
years, especially if there are abrasive solids in
the water. If sand accumulates in the storage
tank or pipes as a result of normal pumping, it
is best to take periodic measurement of the
pump’s performance. A worn pump end can
be replaced in the field.
7 WARRANTY
BADU Top pump and PS-xxx controllers
are warranted by the manufacturer to be
free from defects in material and workman-
ship for two (2) years from date of pur-
chase.
Failure to provide correct installation, opera-
tion, or care for the product, in accordance
with the instruction manual, will void the
warranty. Product liability, except where
mandated by law, is limited to repair or
replacement, at the discretion of the manufac-
turer or importer.
Neither manufacturer nor importer is respon-
sible for the labor or other charges necessi-
tated by the removal, transportation, or
reinstallation of any defective product.
Warranty does not cover damage due to
failure to install the device properly, mishan-
dling or abuse, failure to protect circuitry from
weather exposure, failure to protect from
overheating due to sun exposure or other
sources of heat, failure to protect from salt
spray or other corrosive factors, failure to seal
out insects, spiders or rodents, lightning, flood
or other acts of nature, or failure of or inap-
propriate application of peripheral devices
including lightning or surge protectors.
BADU Top pumps are designed for pumping
thin, clean, non-aggressive, non explosive
liquids not containing solid or long firbred
particles larger then sand grains
Warranty does not cover damage due to sand
or abrasive particles in the water, or incom-
patibility of pump materials with corrosive
substances or hydrocarbon or petroleum
impurities, or from running the pump with an
insufficient supply of water.
No specific claim of merchantability shall be
assumed or implied beyond what is printed on
the manufacturer’s or importer’s printed
literature. No liability shall exist from circum-
stances arising from the inability to use the
product, or its inappropriateness for any
specific purpose. It is the user’s responsibility
to determine the suitability of the product for
any particular use.
In all cases, it shall be the responsibility of the
customer to ensure a safe installation in
compliance with local, state and national
electrical codes.
Manual PS600 BADU Top 12