Mahindra Jivo 365 DI - Checking Radiator Fins; Checking Coolant Level; Checking Engine Oil Level; Primary Check up

12
PRIMARY CHECKUP
Checking Engine Oil Level
 Check the engine oil before starting the engine or ‘5’
minutes or more after the engine has stopped.
 To check the oil level, draw out the dipstick, wipe it
clean, insert it and draw it out again. Check to see that
the oil level lies between the two marks.
 Add oil only when the oil level reaches the lowest mark.
Caution -Do not run the engine if the oil level is low than specified.
1
Checking Coolant Level
 Check coolant level in recovery bottle & Top-up if
required.
 Use redimix coolant for top up.
Warning -Do not open the coolant cap when the engine is hot. Do not
remove the radiator cap when the engine is hot
2
Checking Radiator Fins
 Clean chaff guard daily or earlier if chocked.
 Blow compressed air through the radiator fins to
remove foreign material
Caution -To avoid personnel injury, ensure to stop the engine before
working on radiator.
3
Checking Radiator Fins
 The tension is correct when the belt can be pressed by
thumb to 9 - 12 mm. midway between the two pulleys
without much effort.
 In case the tension is not correct then adjust the tension
by adjusting alternator position on brace plate.
4