30
Trouble shooting
Malfunction System Observation Cause
Chain does not run Chain brake Engine runs Chain brake actuated.
Engine does not start or Ignition system Ignition spark Malfunction in fuel supply system, com-
only with difÞ culty pression system, mechanical malfunction.
No ignition spark Switch on STOP, fault or short-circuit in the
wiring, plug cap or spark plug defective.
Fuel supply Fuel tank is Þ lled Combination switch in Choke position,
carburetor defective, suction head dirty, fuel
line bent or interrupted.
Compression Inside Cylinder base packing ring defective, radial
system shaft packings defective, cylinder or piston
rings defective
Outside Spark plug does not seal.
Mechanical Starter does not engage Spring in starter broken, broken parts
malfunction inside the engine.
Warm start difÞ culties Carburetor Fuel tank is Þ lled Wrong carburetor adjustment.
Ignition spark
Engine starts, but Fuel supply Fuel tank is Þ lled Wrong idling adjustment, suction head or
dies immediately carburetor dirty.
Tank venting defective, fuel line interrupted,
cable defective, Combination switch defective,
Decompression valve dirty
InsufÞ cient power Several systems Engine is idling Air Þ lter dirty, wrong carburetor adjustment,
may be involved mufß er clogged, exhaust channel in cylinder
simultaneously clogged, spark arrester screen clogged.
No chain lubrication Oil tank/pump No oil on the chain Oil tank empty.
Oil guide groove dirty.
Oil-pump adjusting screw incorrectly adjusted.
To Next Page
Loading...
Need help?
General
