Manitowoc National Crane NC1400H - Page 75

National Crane Published 10-30-2014 Control # 040-09 2-19
1400H OPERATOR AND SERVICE MANUAL OPERATING CONTROLS
NATIONAL CRANE CORPORATION
LOAD RATINGS
LOAD
RADIUS
(ft)
LOADED
BOOM
ANGLE
30 ft
BOOM
(lb)
LOADED
BOOM
ANGLE
A
44 ft
BOOM
(lb)
LOADED
BOOM
ANGLE
B
58 ft
BOOM
(lb)
LOADED
BOOM
ANGLE
C
72 ft
BOOM
(lb)
LOADED
BOOM
ANGLE
D
86 ft
BOOM
(lb)
LOADED
BOOM
ANGLE
100 ft
BOOM
(lb)
LOAD
RADIUS
(ft)
LOADED
BOOM
ANGLE
30 ft JIB
(lb)
LOADED
BOOM
ANGLE
54 ft JIB
(lb)
679.166,000 30 78.4 5,500
874.949,200 35 76.5 5,450 78.5 2,650
10 70.6 42,200 77.2 37,900 40 74.6 5,400 76.9 2,600
12 66.3 38,600 74.9 33,400 79.2 29,550 45 72.4 5,100 75.2 2,500
14 61.7 34,200 72.1 29,400 77.1 26,550 80 23,050 50 70.1 4,600 73.4 2,400
16 56.8 30,350 69.2 26,900 75.1 24,550 78.6 21,050 55 67.8 4,250 71.6 2,300
20 46 23,550 63.3 21,400 70.8 19,250 75.3 18,050 78.4 16,800 80 11,600 60 65.5 3,900 69.8 2,200
25 27.4 16,700 55.2 17,400 65.3 16,050 71 14,650 74.9 13,700 77.3 10,950 65 62.7 3,200 67.9 2,100
30 46.1 13,900 59.5
13,550 66.7 12,550 71.3 11,450 74.5 10,550 70 59.9 2,600 66 2,000
35 35 10,350 53.1 10,650 61.9 10,550 67.7 9,900 71.8 9,150 75 57.1 2,050 64 1,850
40 20 8,000 46.8 8,250 57.6 8,400 64.3 8,550 68.4
8,050 80 54.1 1,650 61.8 1,750
45 38.8 6,500 52.4 6,650 60.1 6,750 65.3 6,850 85 51.1 1,250 59.6
1,600
50 29 5,150 46.7 5,300 55.9 5,400 61.9 5,500 90 47.9 950 57.4
1,500
55 12.3 4,150 40.4 4,250 51.5 4,400 58.3 4,450 95 44.5 650 54.8 1,200
60 33.2 3,400 46.7 3,550 54.6 3,600 100 52.2 950
65 23.8 2,750 41.5 2,850 50.7 2,900 105 49.4 700
70 35.7 2,250 46.6 2,300 110 46.6 500
75 28.8 1,750 42.2 1,800
80 19.6 1,350 37.3 1,400
85 31.8 1,050
90 25.2 700
0 11,400 0 7,300 0 4,000 0 1,850 0 900
ADD TO
CAPACITIES
WHEN NO JIB
STOWED (lb)
800 600 450 350 300 250
SERIES 14100H
WITH 30-54 FT JIB
FULL-SPAN
OUTRIGGER
Structural
limit line
with 180 lb
block
HOOK EVATION IN FEET
Structural
limit line
with 180 lb
block
Structural
limit line
with 180 lb
block
Structural limit line
with 54 ft jib deployed
Structural limit line with 30 ft jib deployed
Operating radius from C/L rotation
in feet with unloaded boom
B
O
O
M
L
E
N
G
T
H
I
N
F
E
E
T
RCL OPERATING CODE
OPERATING MODE
01 Main Boom - No Jib Stowed
02 Main Boom - Jib Stowed
03 30 ft Tele Jib
04 54 ft Tele Jib
11 Man Basket on Main Boom
12 Man Basket on 30 ft Tele Jib
13 Man Basket on 54 ft Tele Jib
NOTE:
9. Operate with jib by radius when main boom
is fully extended, if necessary increase boom
angle to maintain loaded radius.
10. Operate with jib by boom angle when main
boom is not fully extended. Do not exceed
rated jib capacities at any reduced boom
lengths.
11. Capacities do not exceed 85% stability.
12. Shaded areas are structurally limited
capacities.
13. Handling of personnel is only permitted with
full span outriggers.
14. All capacities in pounds, angles in degrees,
radii in feet.
15. Loaded boom angles are given as reference
only.
24 ft 6 in FULL SPAN
OUTRIGGER LOCK PINS MUST BE DISENGAGED
LOADLINE EQUIPMENT DEDUCT
Downhaul weight ....... 180 lb
One sheave block ...... 375 lb
Two sheave block ...... 640 lb
Three sheave block ... 870 lb
Four sheave block ..... 970 lb
Reference Only