Marco B36CF - Installing the Gas Line; Test for Gas Leaks

To unlize the Cold Climate Kit, he following ~estrictions
must be met:
A) Thd Cold Climate Kit is forresidential use only. It may
not be used in mobile hcm ktallations.
B) The Fhe?lace mmt be ktl'&d with a minimum 1"
clearance~ocombus.j5les and the cbiiiry mustbp htded
with 3 3" &LT clea,a~ct.
The air inlet must be hstsllzd a mhimm of 7'zbove the
outside gouad level [Figure 3 1).
D) The following clinmey high limits mu;: 5e 03353tid:
1) Far tile BTL-&D, BTLG-ED 2nd BT-ED:
Without elbows: 15' minimum, 60' maximum.
Up en Sow 14) ehows: 14' minimum, 60' mzxhum.
2) Fcr the TST-33; 24' minimum, 60haximm with up to
four (4) elbows. hstallation less than 34* is not ~IowP~.
E) Wlen theairinletmalengsidethehey,itmustnot
md closer than d~rce (3) feet ta the elhey termination as
shown En Figure 29A.
fl Whzn insmation reqiis penetrating fire-resistant
Cooa or ceilings, contact your local building of5ciah for
k
!I
UNION
/
EGUm 32
mORTmT: htzll. fie ,gas ljne b&re fssl-+h~ the
Freplace. 1E desix6, a riecatative gas applj=c:: my be
kralled. Use cnly iron $?e, 113" size, ad a~propriate
fittings. When installing gas line, a valve desiqed for
i~slJa!iap. o~kside hc fi-e?l;ce is required Fipe 32).
me 3s Line may be btalkd to enter the fkapIace from
eihr side. Rder to Pip8 6 for hole locsuca. Tho unit is
sL&&horn the fa~rory ready for installation on the right-
Emd side. To instd in she righthand side, proceed 3s
follm~s: Fist, semeve die. cover krn the outside cf &-
5re~hce cash~ wirh a 5/16" socket wrmch and remove
conduit sleeve. Tske iw;latic!~ material out of the ps Sine
coac!~ir m2ssveForseuse. L~cstethemarkanthrssidapane!
rrf the bside wall of the firebox. It is apprcxima?ely 1 112"
froathe bottom of the Freplace. Uskg a li&t punch, hock
the plug thmugl~ ff~e inside d che fvebox
Rei,mert thc
conduit de~ve.
If a left-had installation is desired, knock out ihe plug in he
fireplace casp on Lhe le5t-hand side. Proceed as for a rig%
]land i.wtaUaticn; however, mike SLY to m~ve The conduit
fie~n the right-hmd side to the left-hmd side. Tl.enrqlace
the cover on the right-hand si je.
Runthe =as ijne just bid~th~ mL%3ce hole ofth~fkile~l~ce.
Lwtsll a 7" mbum ni?de ':o reach inside th; fi~place.
Repack the insulation to fie canduk sleeve :round d~e
nipple, Finish khe ktak?.!ion by eihr capi.1~ the zas line
or attaching a gs lag.
.* . .. .
Tlie g2s line is intended for ccmecti3n te a decorative ps
appliance &at incarpora:es an zurematic sllutoff device and
complies witb he Stanbrd for Decnrati~e Gas Apphees
for htallaticn in Vented Firtplaces, ANSI 221.60. The
Decomtive Gas Appliance must have been insfafled in
accardmce with the Yztfonal Fuel Gas Code, ATST 2223.1
~'d NFPA 54.
CAIJTIQX: WEEX rSmG. THE DECORATIVE AP-
PLZRYCE, TI33 FEEPLA.CE DAMPER MLST RE"
SET LW *~m KXLI' arm POSITEON.
TEST' FOR GAS LEAKS
-411 gas piping md ccnnections must be tested for
Ieaks after theirrdaUationis completed. Besme to
fir71 on the gas valve. Lfb~SMts swear, leak :an
,
be detected a;ld correct~:d.
-4pply a sazp suds
solution to all cmne~timz andjoints. DONOTuse
amatch w open flame of :tny lcind to tentfor ledis.
Never operate any a?pliznce wifll leaky connec-
. , ti~ns. .. .
J