Maytag Performa PYG3200 - Bulkhead Assembly; Valve Coils Removal and Replacement; Gas Pipe and Shut off Valve Assembly Removal and Replacement; Heating Housing Removal and Replacement

88 pages

Save Page as PDF

To Next Page

To Previous Page

Main Page

Contents5
Table of Contents7
Safety Notes9
Section 2. Operation9
Specifications11
Top Assembly11
Installation13
Dryer Location13
Gas Connection Requirements13
Electrical Requirements14
Exhaust Requirements15
Installing the Dryer16
Vent Hood16
Length of Vent16
Connecting the Gas17
Typical Electrical Connections19
Connecting the Electric Model Dryer19
Exhausting the Dryer20
Bottom Exhausting20
Belt Orientation21
Leveling the Dryer22
Side Exhausting22
Operation23
Opening the Door23
Press Care24
Controls24
Auto Dry Permanent Press24
Cycles24
Auto Dry Regular25
Time Dryer/Air Fluff25
Damp Dry25
Wrinkle Release25
Cabinet Assembly Components27
Cabinet and Base Assembly27
Top Assembly27
Front Panel Assembly29
Collector Duct Assembly30
Door Assembly30
Door Seal32
Cylinder Assembly and Related Parts33
Cylinder Belt Replacement34
Cylinder Support Rollers and Glide35
Rear Roller Support Assemblies35
Glide Assembly36
Front and Rear Seals37
Front Seal Replacement37
Rear Seal Replacement37
Blower and Drive Module39
Blower Assembly40
Cover Assembly40
Blower Wheel41
Housing Assembly41
Idler Assembly42
Motor and Pulley Assembly42
Heat Source and Related Parts45
Heater Assembly46
Heater Element Assembly Removal and Replacement47
Gas Control and Burner Assembly47
Silocon Carbide Ignition System48
Gas Control Valve49
Holding Coil49
Booster Coil/Secondary Coil49
Flame Sensor49
Circuit Operation50
Silicon Carbide Igniter50
Normal Ignition50
Safety Features51
Power Interruption51
Ignition Failure51
Ignite Assembly Removal and Replacement52
Part Removal and Replacement52
Burner Assembly Removal and Replacement52
Flame Failure52
Bulkhead Assembly53
Valve Coils Removal and Replacement53
Gas Pipe and Shut off Valve Assembly Removal and Replacement53
Heating Housing Removal and Replacement53
Bulkhead Assembly Removal54
High Limit Thermostat54
Thermal Fuse54
Terminal Block54
Backguard Assembly57
Contact Functions59
Timer59
Resistor59
Electrical Components and Testing59
Wrinkle Release Switch60
Temperature Selector Switch60
Wiring Diagram (Electrical Model)61
Wiring Diagram (Gas Model)63
Switch Testing65
Door Switch Testing65
Silicon Carbide Ignition System Testing65
Heater Element Assembly66
Bias-Heated Thermostats66
No Igniter Glow66
Gas Ignites - Flame Goes out66
Control Thermostat67
Inlet Air Control Thermostat67
Testing Thermostats68
Thermal Fuse Schematic68
Motor Removal69
Motor Testing69
Overload Protection Switch69
Motor Switch69
Wiring Information71
Door Switch71
Controls71
Thermal Fuse71
Motor72
- Motor Switch73
- Holding Coil73
- Dlg23174
- Pye2300, Hye2460, Pyet24475
- Pyg230077
- Pye3200/330079
- Pyg3200/330081
- Pye4500/4557/455883
- Pyg4500/4557/455885
- Hye3657, Hye3658, Pyet34487

Maytag Performa PYG3200 - Bulkhead Assembly; Valve Coils Removal and Replacement; Gas Pipe and Shut off Valve Assembly Removal and Replacement; Heating Housing Removal and Replacement

Table of Contents

Related product manuals