PELLET STOVES Chapter 1
INSTALLATION AND USE MANUAL
page 3
Introduction Technical service - Rights reserved MCZ GROUP S.p.A. - Reproduction prohibited
4.1. PRE-LIGHTING WARNINGS ............................................................................................................ 40
4.2. PRE-LIGHTING CHECK .................................................................................................................. 41
4.3. LOADING THE PELLETS ................................................................................................................. 41
4.4. SUPPLEMENTARY HOPPER CONDUIT (accessory) ............................................................................ 41
4.5. DISPLAY PANEL AND COMMANDS .................................................................................................. 42
4.5.1. Control panel logic .................................................................................................................. 42
4.6. SETTINGS TO CARRY OUT BEFORE FIRST LIGHTING ...................................................................... 44
4.6.1. Setting current day and time ................................................................................................... 44
4.6.2. Setting the language .............................................................................................................. 45
4.6.3. Procedure for recipe selection ................................................................................................. 46
4.7. CONTROL OF WATER TEMPERATURE IN BOILER ............................................................................ 46
4.8. FIRST LIGHTING .......................................................................................................................... 47
4.8.1. Start-up/shutdown from the control panel ................................................................................ 47
4.8.2. Note on first ignition ............................................................................................................... 47
4.9. OPERATING MODE ........................................................................................................................ 48
4.9.1. Operating concept .................................................................................................................. 48
4.9.2. Automatic mode ..................................................................................................................... 48
4.9.2.1.
Room sensor
................................................................................................................... 48
4.9.2.2.
Connecting an external room thermostat (3) or storage tank (3)
.......................................... 49
4.9.3. Automatic mode with AUTO-ECO ............................................................................................. 50
4.9.3.1.
Activation /de-activation of AUTO-ECO mode
..................................................................... 51
4.10. HOT AIR VENTILATION SUITE-CLUB-MUSA 22 KW ...................................................................... 52
4.11. SLEEP FUNCTION ...................................................................................................................... 53
4.12. TIMER ...................................................................................................................................... 53
4.12.1. Current date and clock ........................................................................................................ 53
4.12.2. TIMER activation and selection of a programme. ................................................................... 54
4.12.3. TIMER de-activation. ........................................................................................................... 55
4.13. PRE-SET WEEKLY AND DAILY PROGRAMMES ............................................................................... 55
4.13.1. Weekly programmes............................................................................................................ 55
4.13.2. Daily programmes ............................................................................................................... 57
4.14. PRACTICAL EXAMPLE OF DAILY PROGRAMMING .......................................................................... 58
4.14.1. Setting of a daily programme ............................................................................................... 58
4.15. SAFETY DEVICES ....................................................................................................................... 59
4.16. ALARM SIGNALLING .................................................................................................................. 60
4.17. Exiting alarm condition ............................................................................................................... 62
4.17.1. Shutdown of the stove ........................................................................................................ 62
5. MAINTENANCE AND CLEANING ...................................................................................................... 63
5.1. DAILY OR WEEKLY CLEANING PERFORMED BY THE USER ............................................................... 63
5.1.1. BEFORE EACH IGNITION ........................................................................................................ 63
5.1.2. Check every 2/3 days ............................................................................................................. 63
5.1.3. Clean the exchanger and the undergrate space every 2/3 days. ................................................. 64
5.1.4. Cleaning the glass .................................................................................................................. 65
5.1.5. Cleaning of the air filter .......................................................................................................... 65
5.1.6. Cleaning of stainless steel and satin-finish surfaces ................................................................... 65
5.1.7. Cleaning of painted parts ........................................................................................................ 65
5.2. CLEANING TO BE PERFORMED BY SPECIALIZED TECHNICIAN .......................................................... 66
5.2.1. Cleaning the heat exchanger and the pipe unit ......................................................................... 66
5.2.1.1.
CLEANING THE EXCHANGER AND PIPE UNIT (EGO/STAR)
.................................................. 66
5.2.1.2.
CLEANING THE EXCHANGER AND PIPE UNIT (SUITE/MUSA and CLUB):
............................... 67
5.2.2. Shutting the stove down (end of season) ................................................................................. 68
5.3. CHECK OF INTERNAL COMPONENTS .............................................................................................. 68
6. PROBLEMS / CAUSES / SOLUTIONS ............................................................................................... 70
7. ELECTRICAL DIAGRAMS ................................................................................................................. 73
7.1. HEATING-ONLY VERSION .............................................................................................................. 73
7.2. VERSION THAT PRODUCES DHW .................................................................................................. 74
To Next Page
Loading...
