MDC XT16HR ISLAND - User Manual

To Next Page

1 | Page

www.mdcusa.co m

Ph: 833-632-8721

Page | 1

XT1 6 HR ISLAN D

OFFROAD Travel Trailer

OWNER’S MANUAL

U.S.A. EDITION: 2023 - Version 1

www.mdcusa.com

* 2021 Model shown.

Phone: 833-632-8721

Reserved

Main Page

Table of Contents4
General Safety Information6
- Safety Alert Symbols and Signal Words6
- Reporting Safety Defects6
- Tow Vehicle and Trailer Compatibility6
- Terminology & Abbreviations7
- Secondary Escape8
Fire9
- Ventilation9
- Precautions9
- Combustible Materials9
- Fire Extinguisher9
- In Case of Fire9
Achieving a Safe Towing Combination10
- Trailer Tire Pressures11
- Tow Vehicle Tire Pressures11
- Ball (Coupling) Weight11
- Load Placement11
- Trailer Level11
- Hitch Movement12
- Vehicle Squat12
- Maximum Weight Limits13
Summary14
Tire Safety Information15
- Steps for Determining Correct Load Limit - Trailer15
  - Trailers 10,000 Pounds GVWR or Less15
- Steps for Determining Load Limit - TOW VEHICLE15
- Tire Safety - Everything Rides on It16
- Tire Pressures19
  - Additional Information on Light Truck Tires20
  - Tire Safety Tips20
Propane Safety21
- Gas Certification21
- General Safety21
- Propane Cylinder Safety22
- Gas Appliance Safety23
- Removing Door Vent Cover23
- Isolating Appliances23
Electrical Safety24
- Shore Power24
- GFI Safety Switch24
- Battery Compartment24
  - Brake Controller25
- Jacking Your Trailer25
- Dangerous Gases26
- MDC Contact Details and Stores26
Using Your Trailer27
- Connecting to the Tow Vehicle27
- Loading Your Trailer35
- Pre-Trip Inspection35
- Operating Trailer Features36
- 12 Volt Electrical Syst Em37
  - Control Panel37
Towing Your Trailer38
- Speed and Road Conditions38
- Trailer Sway38
- Fatigue38
- Daily Checks38
- Correct Wiring of Tow Vehicle39
Trail-Assure™ Electronic Stability Control System40
- Choosing a Camp Site44
  - Inclement Weather44
Care and Maintenance of the Trailer45
- Protection of Finishes45
Trailer Body Maintenance46
- Winterizing the Trailer46
  - Water Heater Bypass Installed46
  - Water Heater Bypass Not Installed46
- Post Winter46
- Winter Storage46
Mechanical Maintenance47
- Wheels and Tires47
- Brakes47
- Brake Adjustment47
- Brake Cleaning and Inspection47
- Magnets48
- Shoes and Linings48
Plumbing and Toilet51
- Grey Water Tank51
- Fresh Water Tanks51
- Selecting the Supply Tank51
- Connecting to City Water51
- Toilet Care and Maintenance51
- Truma Aquago Hot Water System52
- Safety Symbols and Signal Words52
- Safety Behavior and Practices52
- Responsibilities of the Operator52
Safe Operation53
- While Driving53
- Safe Handling of Malfunctions54
- Safe Maintenance and Repair54
- Safety Features54
Operating Instructions55
- How the Appliance Works55
Pressure Relief Valve56
- Access Door57
- Removing the Access Door58
- Closing the Access Door58
- Starting the Appliance59
- Inspections before each Use59
Operating Procedures60
- Operating Modes (Control Panel)62
Operation in Frost Conditions63
Winterizing64
Winterizing the Appliance64
Winterizing the RV with a Winterizing Fluid65
- Draining the Water and Cleaning the Water Inlet Filter66
Decalcification68
- Appendix A - Error Codes75
- Troubleshooting76
- Water Pump78
- Selecting Fresh Water Tank78
Furnace79
- Introduction79
- General Safety79
- Operation81
- Turning on the Furnace81
- Turning off the Furnace82
- Inspection and Monthly Maintenance82
Schematics & Part Numbers83
- Spare Part Numbers83
- Electrical Diagram84
- Lithium Battery System85
- Battery Care85
- Lithium (Lifepo4) Battery Reset85
Charging System - BM Pro86
- Batteryplus Trouble Shooting88
- Hub Assembly89
- Trailing Arms and Bushes90
Service Record and Schedule91
- Travel Record113
Warranty Policy115
Guide to Video Tutorials119
- Handover Video119
- Setup Tutorial119
- External Ensuite Setup Tutorial119
- Annex Setup Tutorial119
- Pack down Video Tutorial119
Appendix120

Brand	MDC
Model	XT16HR ISLAND
Category	Caravans
Language	English

MDC XT16HR ISLAND - User Manual

Table of Contents

MDC XT16HR ISLAND Specifications

Related product manuals