Mec 1930SE - Table of Contents

Page ii SE
AC
Slab Series - Operator’s Manual
November 2022
Table of Contents
Section 1 - Introduction . . . . . . . . . . . . . . . . 1
Introduction � � � � � � � � � � � � � � � � � � � � � 1
Section 2 - Safety . . . . . . . . . . . . . . . . . 2
Safety � � � � � � � � � � � � � � � � � � � � � � � 2
Safety Alert Symbols & Fall Protection � � � � � � � � � � � � � � 3
Section 3 - Specications . . . . . . . . . . . . . . . 4
Specications - 1930SE, 2632SE & 3346SE � � � � � � � � � � � � � 4
Specications - 4046SE & 4555SE � � � � � � � � � � � � � � � 5
Section 4 - Hazards . . . . . . . . . . . . . . . . . 6
Electrocution Hazard � � � � � � � � � � � � � � � � � � � 6
Minimum Safe Approach Distance � � � � � � � � � � � � � � � 7
Tip-over Hazards � � � � � � � � � � � � � � � � � � � � 9
Fall & Collision Hazards � � � � � � � � � � � � � � � � � � 10
Additional Safety Hazards � � � � � � � � � � � � � � � � � � 11
Section 5 - Controls & Components . . . . . . . . . . . . 12
Component Locations � � � � � � � � � � � � � � � � � � � 12
Platform Controls � � � � � � � � � � � � � � � � � � � � 13
Lower Controls
� � � � � � � � � � � � � � � � � � � � � 14
Section 6 - Workplace Inspection . . . . . . . . . . . . . 15
Workplace Inspection � � � � � � � � � � � � � � � � � � � 15
Section 7 - Operating Instructions & Functions Test . . . . . . . . 16
Functions Test � � � � � � � � � � � � � � � � � � � � � 16
Operating Instructions � � � � � � � � � � � � � � � � � � � 20
Maintenance Lock � � � � � � � � � � � � � � � � � � � � 24
Sheet Materials Rack - 1930SE, 2632SE & 3346SE Models Only
� � � � � � � 28
Section 8 - Battery Charging . . . . . . . . . . . . . . 29
Battery Charging � � � � � � � � � � � � � � � � � � � � 29
Section 9 - Maintenance. . . . . . . . . . . . . . . . 30
Maintenance � � � � � � � � � � � � � � � � � � � � � 30
Routine Maintenance
� � � � � � � � � � � � � � � � � � � 32
Lubrication� � � � � � � � � � � � � � � � � � � � � � 33
Pre-Start Inspection Checklist � � � � � � � � � � � � � � � � � 34
Frequent Inspection Checklist � � � � � � � � � � � � � � � � � 35
Maintenance Inspection Report
� � � � � � � � � � � � � � � � 36
Section 10 - Warning and Instructional Decals . . . . . . . . . 37
Decals - 1930SE � � � � � � � � � � � � � � � � � � � � 37
Decals - 2632SE & 3346SE � � � � � � � � � � � � � � � � � 39
Decals - 4046SE & 4555SE
� � � � � � � � � � � � � � � � � 41
Serial Plate � � � � � � � � � � � � � � � � � � � � � 43