MOONEY INTERNATIONAL CORPORATION
M20V SERVICE AND MAINTENANCE MANUAL
Page
Date
6
MAR 2017
Rev Date
5-10-00 - TIME LIMIT COMPONENTS
It is recommended that overhaul or replacement of
components should be accomplished not later than the
specified period of operation for that component or in
accordance with manufactures service data or airwor-
thiness directives.
The specified overhaul time limits, if applicable to a
component, do not constitute a guarantee that the com-
ponent will reach that time limit without requiring main-
tenance. “On Condition” replacement and/or servicing
of components should occur when an item exhibits ab-
normal conditions and/or symptoms other than fulfilling
its intended purpose.
-NOTE-
“ONCONDITION”itemsaretoberepaired,re-
placed or overhauled when inspection or perfor-
mance reveals an unserviceable condition.
5- 10- 01 - OVERHAUL, MAINTENANCE AND REPLACEMENT SCHEDULE
ITEM RECOMMENDED OVERHAUL, MAINTENANCE OR
REPLACE TIME LIMITS
Landing Gear (Chapter 32)
Actuator No- Back Spring Refer to MAC SERVICE BULLETIN M20- 282A
All other Components On Condition
Powerplant (Chapter 71)
Engine Refer to Engine Manufacturer’s Continued Airworthi-
ness Data for specific Time Limits. Mooney has no
special requirements over those found in the Manu-
facturer’s Data.
Propeller (See Special Note below) Refer to Propeller Manufacturer’s Continued Airwor-
thiness Data for specific Time Limits. Mooney has no
special requirements over those found in the Manu-
facturer’s Data.
Propeller Governor Refer to Continental/Bendix Manufacturer’s Contin-
ued Airworthiness Data for specific Time Limits.
Mooney has no special requirements over those
found in the Manufacturer’s Data.
Magnetos - BENDIX Refer to Continental/Bendix Manufacturer’s Contin-
ued Airworthiness Data for specific Time Limits.
Mooney has no special requirements over those
found in the Manufacturer’s Data.
Induction Air Filter 500 Hours or Annually
All other Components On Condition
Fuel & Oil System (Chapters 73 & 79)
Fuel Selector Valve (Airight or Christopher Tool) On Condition
Flexible Hoses (All, except Teflon & as below) 7 years or Engine O/H, whichever occurs first.
All other Components (includes Teflon hoses) On Condition
Instruments (Chapter 39)
Other Components On Condition
Electrical System (Chapter 91)
All Components On Condition
Flight Controls (Chapter 27)
All Components On Condition
TKS Airframe/Propeller Pump Motor (Optional) 2000 Hours
Speedbrakes (if equipped) Refer to Precise Flight Installation Manual #08059B
(Also See MAC chapter 27-96-00)
5-10-00
To Next Page
Loading...
