Mooney M20V - Page 36

MOONEY INTERNATIONAL CORPORATION
M20V SERVICE AND MAINTENANCE MANUAL
Page
Date
7
MAR 2017
Rev Date
Lights (Chapter 33)
Position and Anti- Collision Lights LED: On Condition
Note: LED lighting must have all LED segments
operational. If one or more segments have failed, the
entire light assembly must be replaced.
Miscellaneous Systems
E.L.T. Battery (Chapter 39) Refer to ELT Manufacturer’s Continued Airworthiness
Data
Oxygen System Components (Chapter 35)
Precise Flight Oxygen System
Check Breathing Stations 50 hours
Oxygen Cannulas and Standard Masks (Clear) Replace - 200 hours
Oxygen Face masks with Microphone (Blue) Replace/Overhaul - 500 Hours
O- Rings in CPC connectors on Breathing Stations Replace - 3 Years
A4 and/or A5 Constant Flowmeters and
PreciseFlow Oxygen Conservers
Replace/Overhaul - 5 Years
A/C with Solid Green (Kevlar) Bottle P/N 026N2001- 3 - Hydrostatic Test Required @ 3 year intervals.
A/C with Striped Green (Carbon) Bottle P/N 026N2003- 3 - Hydrostatic Test Required @ 5 year intervals.
Oxygen Bottle (return to Precise Flight) Replace - 15 Years
Air Conditioning Components (Optional)
(Chapter 21)
See Section 21- 58- 00 for specific maintenance and
servicing times.
All Other Components (Excluding Avionics) On Condition (See NOTE above)
Avionics (Chapters 39 & 91) Also Refer to Manufacturers Publications
SPECIAL NOTE - REFER to HARTZELL Owner’s Manual 115N:
Hartzell recommends that new or newly overhauled propellers be lubricated after the first one or two hours of
operation because centrifugal loads will pack and redistribute grease, which may result in a propeller imbalance.
Redistribution of grease may also result in voids in the blade bearing area where moisture can collect.
NOTE:
Components should be inspected and serviced at regular intervals per the servicing, lubrication and
inspection chart of this manual.
5-10-01