Napa 791-2320 B - User Manual

791-2300 B, 791-2320 B 1 rev. 03/12/18
SPECIFICATIONS
791-2300 B 791-2320 B
Capacity ........................................12 Ton ...................... 20 Ton
Minimum Height .......................... 10-1/4" .....................10-3/8"
Ram Travel .................................... 6-3/4" .......................6-1/4"
Screw Extension ........................... 3-1/8" .......................3-1/4"
Maximum Height ......................... 20-1/8" .....................19-7/8"
Air Pressure ........................... 110 to 120 PSI .........110 to 120 PSI
Shipping Weight ......................... 28.2 lbs. ....................34.7 lbs.
MODEL # 791-2300 B, 791-2320 B
12 & 20 TON CAPACITY
AIR BOTTLE JACK
BEFORE USING THIS DEVICE, READ THIS
MANUAL COMPLETELY AND THOROUGHLY,
UNDERSTAND ITS OPERATING
PROCEDURES, SAFETY WARNINGS AND
MAINTENANCE REQUIREMENTS.
It is the responsibility of the device owner to make sure all personnel
read this manual prior to using the device. It is also the responsibility
of the device owner to keep this manual intact and in a convenient
location for all to see and read. If the manual or product labels are lost
or not legible, contact NAPA for replacements. If the operator is not
fluent in English, the product and safety instructions shall be read to
and discussed with the operator in the operator's native language by
the purchaser/owner or his designee, making sure that the operator
comprehends its contents.
WARNING
WARNING: This product can expose you to chemicals
including nickel, which is known to the State of
California to cause cancer and birth defects or other
reproductive harm. For more information go to www.
P65Warnings.ca.gov.
S
A
F
E
T
Y
S
T
A
N
D
A
R
D
C
O
M
P
L
I
E
S
I
T
H
W
ASME PASE-2014
• Read, study, understand & follow all instructions before us-
ing. • Inspect the jack before each use. Do not use if damaged,
altered, modied, in poor condition, leaking hydraulic uid or un-
stable due to loose or missing components. Make corrections
before using. • Lift only at points of the vehicle as specied by
the vehicle manufacturer. • User and bystanders must wear eye
protection that meets ANSI Z87.1 and OSHA standards. • Do
not exceed rated capacity. • No persons should be under vehicle
when jack is in use. • This is a lifting device only. Immediately
after lifting, support the vehicle with appropriate means.
• No alterations shall be made to this product. • Use only on a
hard level surface. • Always lower the jack slowly and carefully.
• Do not use saddle adaptors or saddle extenders between the
stock lifting saddle and the load. • Center load on saddle. Be
sure setup is stable before working on vehicle. • Failure to heed
these warnings may result in serious or fatal personal injury and/
or property damage.

Summary

Before Using This Device

General Safety Warnings

Critical safety instructions and warnings for operating the air bottle jack.

Warning Information and Hazards

Nature of Hazardous Situations

Explanation of inherent hazards associated with bottle jack operation.

Methods to Avoid Hazardous Situations

Essential steps and precautions to prevent accidents during jack use.

Consequences of Not Avoiding Hazardous Situations

Details the serious risks of injury or damage from non-compliance.

Assembly and Operating Instructions

Assembly Instructions

Step-by-step guide for assembling the bottle jack and preparing it for use.

Purging Air from Hydraulic System

Method to remove air from the hydraulic system for optimal jack performance.

Operating Instructions

Crucial guidelines for safe and effective operation of the air bottle jack.

Maintenance and Troubleshooting

Preventative Maintenance

Procedures for maintaining the jack's air motor and hydraulic system.

Adding Oil

Instructions for checking and adding hydraulic jack oil to the reservoir.

Troubleshooting

Common jack issues, their causes, and corrective actions.

Warranty

Information on obtaining warranty service and details.

Napa 791-2320 B Specifications

General

Brand	Napa
Model	791-2320 B
Category	Jacks
Language	English