Napoleon 9700 SERIES - User Manual

W415-1064 / 11.11.11
1
$10.00
INSTALLER: PLEASE FAMILIARIZE YOURSELF WITH VENTING/DRAINING SECTIONS OF
THIS MANUAL BEFORE PROCEEDING WITH THE INSTALLATION. LEAVE
THIS MANUAL WITH THE APPLIANCE FOR FUTURE REFERENCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.
INSTALLATION AND
OPERATING INSTRUCTIONS
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada /
103 Miller Drive, Crittenden, Kentucky, USA, 41030
Phone (705)721-1212 • Fax (705)722-6031 • www.napoleonheatingandcooling.com • ask@napoleonproducts.com
SAFETY INFORMATION
ELECTRICAL SHOCK, FIRE OR
EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death or
property damage.
Improper servicing could result in
dangerous operation, serious injury, death
or property damage.
- Installation and service must be performed by a
qualifi ed installer, service agency or the gas supplier.
- Before servicing, disconnect all electrical power to
furnace.
- When servicing controls, label all wires prior to
disconnecting. Reconnect wires correctly.
- Verify proper operation after servicing.
- Do not store or use gasoline or other fl ammable
vapors and liquids in the vicinity of this or any other
appliance.
- WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a
neighbour’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call the fi re
department.
!
WARNING
!
MANUFACTURER RESERVES THE RIGHT TO DISCONTINUE, OR CHANGE
AT ANY TIME, SPECIFICATIONS OR DESIGNS WITHOUT NOTICE AND
WITHOUT INCURRING OBLIGATIONS.
Patent Pending
CERTIFIED TO ANSI Z21.47b / CSA 2.3b-2008
98%
90%
97.0
Annual Fuel Utilization Efficiency (AFUE)
Gas- or Propane-fired forced-air furnace
with a high efficiency motor
9700 SERIES
TWO STAGE HIGH EFFICIENCY
(CONDENSING) FORCED AIR GAS FURNACE

Summary

SAFETY INFORMATION

ELECTRICAL SHOCK, FIRE OR EXPLOSION HAZARD

Warning about hazards from incorrect installation or servicing, leading to injury, death, or property damage.

WHAT TO DO IF YOU SMELL GAS:

Emergency procedures to follow if gas is detected, including evacuation and contacting authorities.

2.1 SAFETY RULES

5.0 COMBUSTIBLE CLEARANCES

7.0 VENTING AND COMBUSTION PIPING

8.0 NON-DIRECT VENT FURNACE INSTALLATIONS

Combustion Air Requirements

Warnings and cautions regarding combustion air for furnace operation.

8.1 DETERMINING COMBUSTION AIR

9.0 VENTING GUIDELINES

Vent Termination Guidelines

Guidelines for properly terminating vent pipes to prevent issues.

11.0 CONDENSATE DRAINS

12.0 GAS SUPPLY AND PIPING

13.1 CHECKING THE INLET GAS PRESSURE

13.2 SETTING THE MANIFOLD GAS PRESSURE

14.0 ELECTRICAL SPECIFICATIONS

Electrical Wiring and Connections

17.0 STARTUP PROCEDURES

Furnace Startup and Shutdown

Step-by-step procedures for starting and shutting down the furnace.

17.3 SEQUENCE OF OPERATION

18.0 AIR FLOW

Temperature Rise Check

19.0 MAINTENANCE AND TROUBLESHOOTING

19.6 ANNUAL INSPECTION;SERVICE

19.7 TROUBLESHOOTING FLOWCHART

19.8 DIAGNOSTIC CODES FOR STATUS LED

4.0 ROUTINE MAINTENANCE BY HOMEOWNER

3.0 FURNACE OPERATION INFORMATION

Furnace Startup and Shutdown Procedures

Step-by-step procedures for starting and safely shutting down the furnace.

2.1 GENERAL SAFETY RULES

2.0 SAFETY ISSUES

Napoleon 9700 SERIES Specifications

General

Heat Exchanger	Stainless Steel
Input BTU/h	40, 000 - 120, 000
Fuel Type	Gas
Blower Motor	Variable Speed
Warranty	Limited Lifetime on Heat Exchanger, 10 Years on Parts