2
W415-0663 / E / 08.23.12
NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.
TABLE OF CONTENTS
1.0 INSTALLATION OVERVIEW 3
2.0 INTRODUCTION 4
2.1 DIMENSIONS 5
2.1.1 BGD34-1 DIMENSIONS 5
2.1.2 GD34-1 DIMENSIONS 5
2.2 GENERAL INSTRUCTIONS 6
2.3 GENERAL INFORMATION 7
2.4 RATING PLATE INFORMATION 7
3.0 VENTING 8
3.1 VENTING LENGTHS AND COMPONENTS 8
3.2 TYPICAL VENT INSTALLATION 9
3.3 SPECIAL VENT INSTALLATIONS 10
3.3.1 PERISCOPE TERMINATION 10
3.4 VENT TERMINAL CLEARANCES 11
3.5 VENTING APPLICATION FLOW CHART 12
3.6 DEFINITIONS 12
3.7 ELBOW VENT LENGTH VALUES 12
3.8 HORIZONTAL TERMINATION 13
3.9 VERTICAL TERMINATION 15
4.0 INSTALLATION 17
4.1 WALL AND CEILING PROTECTION 17
4.1.1 HORIZONTAL INSTALLATION 18
4.1.2 VERTICAL INSTALLATION 18
4.2 USING FLEXIBLE VENT COMPONENTS 19
4.2.1 HORIZONTAL AIR TERMINAL INSTALLATION 19
4.2.2 VERTICAL AIR TERMINAL INSTALLATION 20
4.2.3 APPLIANCE VENT CONNECTION 21
4.3 USING RIGID VENT COMPONENTS 21
4.3.1 HORIZONTAL AIR TERMINAL INSTALLATION 21
4.3.2 EXTENDED HORIZONTAL AND CORNER TERMINAL INSTALLATION 22
4.3.3 VERTICAL AIR TERMINAL INSTALLATION 22
4.4 GAS INSTALLATION 23
4.5 OPTIONAL WALL SWITCH 23
4.6 HARD WIRE INSTALLATION 23
4.7 VERTICAL THROUGH EXISTING CHIMNEY 24
4.8 MOBILE HOME INSTALLATION 25
5.0 FRAMING 26
5.1 GD34-1 FRAMING 26
5.1.1 MINIMUM FRAMING DIMENSIONS 27
5.2 BGD34-1 FRAMING 28
5.2.1 MINIMUM FRAMING DIMENSIONS 29
5.3 MINIMUM CLEARANCE TO COMBUSTIBLE ENCLOSURES 30
5.4 ALCOVE FRAMING 31
5.5 MINIMUM MANTEL CLEARANCES 32
6.0 FINISHING 33
6.1 DOOR REMOVAL AND INSTALLATION 33
6.2 LOG PLACEMENT 34
6.3 BGD34-1 34
6.3.1 GLOWING EMBERS 34
6.4 GD34-1 35
6.4.1 GLOWING EMBERS 35
6.5 CHARCOAL EMBERS 36
6.6 LOUVRE INSTALLATION 36
6.7 LOGO PLACEMENT 36
7.0 OPTIONAL BLOWER INSTALLATION 37
8.0 OPERATION 38
9.0 ADJUSTMENT 39
9.1 PILOT BURNER ADJUSTMENT 39
9.2 VENTURI ADJUSTMENT 39
9.3 FLAME CHARACTERISTICS 40
9.4 RESTRICTING VERTICAL VENTS 40
10.0 MAINTENANCE 41
10.1 CARE OF GLASS 41
10.2 CARE OF PLATED PARTS 41
10.3 DOOR GLASS REPLACEMENT 42
11.0 REPLACEMENTS 43
12.0 TROUBLESHOOTING 47
13.0 WARRANTY 50
14.0 SERVICE HISTORY 51
f i r e - p a r t s . c o m
To Next Page
