Napoleon EPA 1150 User Manual

W415-1468 / A / 09.30.16
EN
FR
PG
45
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.
NEVER LEAVE CHILDREN OR OTHER AT RISK INDIVIDUALS ALONE WITH THE APPLIANCE.
This wood appliance needs periodic inspection and repair for proper operation. It is against United States federal
regulation to operate this wood appliance in a manner inconsistent with operating instructions in this manual.
INSTALLATION AND
OPERATING INSTRUCTIONS
1.27D
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada /
103 Miller Drive, Crittenden, Kentucky, USA, 41030
Phone (705)721-1212 • Fax (705)720-9081 • www.napoleonfi replaces.com • hearth@napoleonproducts.com
SAFETY INFORMATION
!
WARNING
If the information in these instructions is not followed exactly, a
fi re or explosion may result causing property damage, personal
injury or death. Improper installation, adjustment, alteration,
service or maintenance can cause injury or property damage,
bodily injury or even death. Please read entire manual before
you install and use your appliance.
This appliance has not been tested with an unvented gas log
set. To reduce risk of fi re or injury, do not install an unvented
gas log set into the appliance.
- This appliance can be very hot when burning.
- Combustible materials such as fi rewood, wet clothing, etc. placed too close
can catch fi re.
- Children and pets must be kept from touching the appliance when it is hot.
- The chimney must be sound and free of cracks. Before installing this unit,
contact the local building or fi re authority and follow their guidelines.
- Operate only with the door tightly closed.
- Burn wood behind the log retainer directly on the fi rebricks.
- Do not use an elevated grate or otherwise raise the fi re.
- At least 14 square inches (90.3 square centimeters) of outside air must be
admitted to the room or directly to the unit through a 4” (101.6mm) diameter
pipe.
- This appliance is designed to burn natural wood only. Higher effi ciencies and
lower emissions generally result when burning air dried seasoned hardwoods,
as compared to softwoods or to green or freshly cut hardwoods.
- Do not start a fi re with chemicals or fl uids such as gasoline, engine oil, etc.
- Do not burn trash or garbage, lawn clippings / waste, rubber, waste petroleum
products, paints or paint thinners / solvents, plastic, materials containing
asbestos, construction debris, railroad ties or treated wood, manure or animal
remains, salt water driftwood or salted materials, unseasoned wood, coal,
charcoal, coloured paper, cardboard, plywood or particleboard.
- Do not let the appliance become hot enough for any part to glow red.
- KEEP THE STOVE TOP TEMPERATURE BELOW 700°F (371°C). Attempts to
achieve heat output rates that exceed design specifi cations can result in steel
distortion and damage.
$10.00
HOT GLASS WILL CAUSE
BURNS.
DO NOT TOUCH GLASS UNTIL
COOLED.
NEVER ALLOW CHILDREN TO
TOUCH GLASS.
!
WARNING
EPA 1100, 1150
1400, 1450 & 1900
PEDESTAL MODELS
MODELS 1100, 1150, 1400, 1450 & 1900 MEET THE 2015 U.S ENVIRONMENTAL PROTECTION AGENCY (E.P.A.) CRIB WOOD EMISSION LIMITS FOR WOOD
STOVES SOLD AFTER MAY 15, 2015, 40 C.F. R. PART 60. THESE STOVES HAVE BEEN TESTED AND LISTED BY INTERTEK TESTING SERVICES TO STANDARDS:
CSA B366.2, ULC S627, UL 1482. MODEL 1100 HAS BEEN TESTED AND LISTED FOR INSTALLATION IN MOBILE HOMES.

Napoleon EPA 1150 Specifications

General

Brand	Napoleon
Model	EPA 1150
Category	Indoor Fireplace
Language	English

Summary

INSTALLATION OVERVIEW

INTRODUCTION

DIMENSIONS

Physical measurements and specifications of the appliance.

SPECIFICATIONS

Technical details including heat output, capacity, and weight.

GENERAL INSTRUCTIONS

Key safety and installation guidelines for operation.

GENERAL INFORMATION

Explains how the appliance works and safety precautions.

RATING PLATE INFORMATION

Details found on the appliance's rating plate.

PRE-INSTALLATION PREPARATION

APPLIANCE PLACEMENT

Proper positioning of the appliance for safe operation and clearances.

CLEARANCE TO COMBUSTIBLES

Minimum required distances from the appliance to combustible materials.

ALCOVE INSTALLATION

Specific guidelines for installing the appliance within an alcove.

FLOOR PROTECTION

Requirements for non-combustible floor protection beneath the appliance.

OUTSIDE AIR

Connecting the appliance to an outside air source for combustion.

OUTSIDE AIR - MOBILE HOME

Specific procedure for connecting outside air in mobile homes.

INSTALLATION

CHIMNEY

Crucial safety and installation guidelines for the chimney system.

CHIMNEY CONNECTION

How to properly connect the appliance to the chimney.

ADDING SECTIONS

Guidelines for extending the chimney and maintaining clearances.

TYPICAL THROUGH THE CEILING

Instructions for routing the chimney through a ceiling.

TYPICAL THROUGH THE WALL

Instructions for routing the chimney through a wall.

TYPICAL EXISTING MASONRY

Connecting the appliance to an existing masonry chimney.

FINISHING

DOOR REMOVAL / INSTALLATION

Procedures for removing and installing the appliance door.

DOOR AND HANDLE INSTALLATION

Steps for installing the door and its handle.

ORNAMENTAL TRIVET INSTALLATION

How to install the ornamental trivet.

PEDESTAL TRIM INSTALLATION (IF SUPPLIED)

Installing the optional pedestal trim.

BRICKS AND BAFFLE INSTALLATION

Correct placement of internal firebricks and baffles.

1150 FEATURES

Highlights specific features of the 1150 model.

OPTIONAL KIT INSTALLATIONS

OPTIONAL BLOWER KIT INSTALLATION

Instructions for installing the optional blower kit.

OPERATION

OPTIMUM BURN METHOD

Guidelines for achieving efficient and clean wood burning.

AIR CONTROL

How to adjust the air control for optimal draft and burn rate.

FIRE EXTINGUISHERS / SMOKE & CARBON MONOXIDE DETECTORS

Recommendations for essential fire safety equipment.

FUEL

Information on suitable fuels, moisture content, and storage.

LIGHTING A FIRE

Step-by-step guide to safely starting a fire.

FLASH FIRE

How to start a small fire for quick heat generation.

EXTENDED FIRE

How to achieve a longer, sustained burn from a fire.

SMOKING

Common causes and solutions for appliance smoking issues.

MAINTENANCE

ASH REMOVAL PROCEDURES

Safe procedures for removing accumulated ashes from the firebox.

CREOSOTE FORMATION AND REMOVAL

Understanding and safely removing creosote buildup in the chimney.

RUNAWAY OR CHIMNEY FIRE

Critical procedures for handling and preventing chimney fires.

CHIMNEY CLEANING

Procedures for inspecting and cleaning the chimney system.

GLASS REPLACEMENT

Steps for safely replacing the appliance's glass door.

GASKET REPLACEMENT

Replacing worn or damaged door and airwash gaskets.

SECONDARY AIR MANIFOLD REPLACEMENT

Procedure for replacing the secondary air manifold assembly.

CARE OF GLASS

How to properly clean and care for the appliance glass.

CARE OF PLATED PARTS

Maintenance tips for the appliance's plated surfaces.

WOOD

Information on fuel types, moisture content, and wood storage.

REPLACEMENTS

EPA 1100 OVERVIEW

Diagram and part list for the EPA 1100 model.

EPA 1150 OVERVIEW

Diagram and part list for the EPA 1150 model.

EPA 1400 OVERVIEW

Diagram and part list for the EPA 1400 model.

EPA 1450 OVERVIEW

Diagram and part list for the EPA 1450 model.

EPA 1900 OVERVIEW

Diagram and part list for the EPA 1900 model.

ACCESSORIES

TROUBLESHOOTING

WARRANTY

SERVICE HISTORY