Nordic ND6 User Manual

Installation and Operating Instructions
Models: ND6 and ND8 (UL#’s 1712-60-0204
and 1712-80-0204) with separate control.
Nordic Deluxe Sauna Heaters
Read all instructions carefully before installation.
Please leave all instructions and warranty with
the owner.
WARNING
Prolonged exposure to elevated temperatures is
capable of inducing hyperthermia. Hyperthermia
occurs when the internal temperature of the body
reaches several degrees above the normal body
temperature of 98.6°F. The symptoms of hyper-
thermia include an increase in the normal tem-
perature of the body, dizziness, lethargy, drowsi-
ness, and fainting. The effects of the hyper-
thermia include failure to perceive heat, failure to
recognize the need to exit the room, unaware-
ness of impending hazard, fetal damage in preg-
nant women, physical inability to exit the room,
and unconsciousness.
WARNING
The use of alcohol, drugs, or medication is
capable of greatly increasing the risk of fatal
hyperthermia.
Section 1: General Information
These heaters are UL approved for permanent
installations and electrical connections. Built with
splash proof construction, the conducting parts
are protected against water. All wiring must be
performed in accordance with local codes. See
Diagram 2 for wire and room size requirements.
These heaters are wall mounted, 16W x 11D x
23H
!
Do not take a sauna if using alcohol, drugs
or medications.
Pregnant women or persons with poor
health should consult their physician before
using a sauna.
Caution fire hazard: Do not use the sauna
room for drying clothes, bathing suits, etc.
Do not hang towels above the heater or
place any object other than rocks supplied
on the heater. If any darkening of the wall
around the heater is noticed discontinue
sauna use immediately.
Inspect sauna regularly for required mainte-
nance to heater, control and benches.
Replace wood surfaces which show any
signs of deterioration.
The heater gets extremely hot during
operation and should not be touched or
burns may result.
Minors should be adequately supervised
whenever near a hot or warming sauna.
WARNING
Page 1

Nordic ND6 Specifications

General

Power	2000W
Voltage	220-240V
Frequency	50Hz
Thermostat	Adjustable
Safety Features	Overheat Protection

Summary

General Information and Safety Warnings

Nordic Deluxe Sauna Heater Introduction

Overview of the Nordic Deluxe Sauna Heaters and critical initial safety warnings.

Installation and Mounting

Heater Mounting and Clearances

Instructions for mounting the heater and maintaining required clearances from combustible materials.

Rock Placement and Electrical Hook-Up

Guidance on placing sauna rocks and performing electrical connections according to code.

Sensor and Guard Rail Installation

Procedures for installing the temperature sensor and the protective heater guard rail.

Operation of Control Panels

SC-9 Control Panel Operation Details

How to operate the SC-9 control panel, including temperature, time, and light settings.

SC-60 Control Panel Operation Details

How to operate the SC-60 control panel, including temperature, time, and light settings.

Safety Procedures and Usage Guidance

High Limit Control Reset and Sauna Usage

Information on the high limit control reset and recommended practices for taking a sauna.

SC-CLUB Control Panel Operation

SC-CLUB Panel Temperature and Start Control

Setting temperature and starting the heater using the SC-CLUB control panel.

SC-CLUB Panel Light Switch Usage

Operation of the sauna room light via the SC-CLUB control panel.

Room Requirements and Safety Placards

Sauna Room Construction and Door Rules

Requirements for sauna room construction, door operation, and electrical fittings.

Warning Placard Placement Guidelines

Instructions for attaching CAUTION and WARNING placards to the sauna room.

Ventilation, Maintenance, and Troubleshooting

Sauna Ventilation Requirements

Specifications and formulas for achieving proper sauna room ventilation.

Heater and Sauna Maintenance Procedures

Guidelines for cleaning and maintaining the sauna heater and room components.

Troubleshooting and Service Contact

Contact information for support and troubleshooting of the sauna heater.