Oceanic EOS - Page 5

EOS SERVICE PROCEDURE 12-2810-R02 (10/3/10)
!"##$%&'(&$))*+%,,'((-..*/01*0/-0(2(+34 '((15.*167*1/./(2(,839)'((:;<=>?;@A?;BC>?D:BE?AF 5
G$&,'(KA(CAR(<; FA=;(RN ;(!T<>CU(+AQQAV;<(W56Y(S<AF(RN;(3 OhD:RF;CR(!NBSR(W5\Y( DCQ; ::(>R(>:(OBFBU;O(BCO(C;;O:(
<;TQB?>C Uf(A<(O;d<>:(C;;O:(RA(d;(<;FA=;O(RA(?Q;BC(>RE(9C(RN>:(?B:;f(< ;FA=;(dP(RD <C>CU(RN;(!T<>CU(+AQQAV;<(W56Y(
?QA?bV>:;(V N>Q;(NAQO >CU(R N;(3OhD:RF;CR(!NBSR(W5\Y (>C(PAD<(ARN; <(NBCOE(GAR;(RNBR(RN; (RN<;BO(> :(Q;SR(NBCO;OE!!
12. The!#ATT;R(!T< >CU(W 51Y(i s!schedule!A,!discard!and!do!not!reuse.!W+>UE(1Y.!
! ! !
!!!!!!! !!!!!!!!+>UE(/( ( ( ( (((((+ >UE(1(( ( ( ((((((((((((((((((+>UE(6(
13. Remove!the!MBQ=;(ZAD: >CU(GDR(W 06Y!with!a!13/16”!open!end!wrench!by!turning!counter!clockwise!W+>UE(6Y.!
14. Carefully!push!the!MBQ=;!ZAD:>C UX3OhD:RF;CR(&Dd;(3::;FdQP!out!through!the!ZAD:>CU(W6Y,!being!careful!not!to!
damage!the!K;FBCO();=;<(W_-Y(and!set!aside!W+>UE(\Y.!
15. Remove!the!%BR?N;R(K; R;CR(W/5Y (and!$*< >CU(W/_Y(with!a!small!flat!blade!screwdriver;!discard!and!K$(G$&(%,"!, !
(schedule!A)!W+>UE(-Y.!
16. Slide!the!M;CRD<>(&Dd;(!V>R?N(W01Y(o ff!the!3OhD:RF;CR(&Dd;(W55Y.!Rem ove!the!M;CRD<>(&Dd;(!V> R?N($*<>CU(W0 /Y(by!
pinching!the!o‐ring!and!rolling!off!W+>UE(7Y ;!inspect !for!any!dam age!and!discard!i f!found.!
! ! !
! ! !!!+>UE(\( ( ( ( ((((+>UE(-( ( ( ( ((( ((((((((((((((( (((((((+>UE(7(
17. Remove!the!3OhD:RF;CR(&Dd;(W55Y(from!the!MBQ=;(ZAD:>CU(W_\(A<( //Y!by!holding!the!square!flats!of!the! MBQ=;(
ZAD:>CU(W_\( A<(//Y(with!a n!11/16”!open!end!wrench!and!insert!a!5/16”!hex!driv er!into!the!3OhD:RF;CR(&Dd;(W55Y( and!
turn!clockwi se;!the!thread!is!left!handed!(+>UE(5.Y.!
18. Remove!the!3OhD:RF;CR(&Dd;($*<>CU(W5_Y(by!squeezing!w ith!your! fingers!and!examine!for!damage;!discard!i f!any!
found.!
19. Remove!the!JBQBC?;(!NBSR($*<>CU(W50Y(located!inside!the!smal l!opening!end!of!the! 3OhD:RF ;CR(&Dd;(W55 Y!by!pres sing!
it!out!with!a!5/64”!p in!punch.!!Discar d!the!$*<>CU(W50Y((schedu le!A)!and!K$(G$&(%, "!,.!W+>UE(55Y.!
20. Examine!the!K;FBCO();=;<(W_-Y(to!insure!that!it!is!not!bent!or!deformed.!If!the!K;FBCO();=;<(W_-Y(is!deformed,!
rem ove!by!pulling!outward!o n!one!leg!of!the!lever!with!your!finger s!un til!it!is!removed!from !the!hole!in!the!s ide!of!the!
MBQ=;(ZAD:>CU(W_\(A<(//Y;!repeat!with!the!other!side.!
!