Perkins 1106C-E70TA - Maintenance Interval Schedule

i09734412
Maintenance Interval Schedule
Oil specification will depend on the engine power.
Refer to this Manual, “Fluid Recommendation” for
more information.
Maintenance intervals will change if high sulfur fuels
are used and biodiesel. Refer to this Manual, “Fluid
Recommendation” for more information.
When Required
“ Battery - Replace“ . . . . . . . . . . . . . . . . . . . . . . . . . 74
“ Battery or Battery Cable - Disconnect“. . . . . . . . . 75
“ Engine - Clean“ . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
“ Engine Air Cleaner Element (Single Element) -
Inspect/Replace“ . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
“ Engine Oil Sample - Obtain“ . . . . . . . . . . . . . . . . . 87
“ Fuel System - Prime“. . . . . . . . . . . . . . . . . . . . . . . 91
Daily
“ Driven Equipment - Check“ . . . . . . . . . . . . . . . . . . 80
“ Engine Air Cleaner Service Indicator - Inspect“. . 84
“ Engine Air Precleaner - Check/Clean“ . . . . . . . . . 85
“ Engine Oil Level - Check“ . . . . . . . . . . . . . . . . . . . 86
“ Fuel System Primary Filter/Water Separator -
Drain“ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
“ Walk-Around Inspection“ . . . . . . . . . . . . . . . . . . . 100
Every Week
“ Hoses and Clamps - Inspect/Replace“. . . . . . . . . 98
Every 50 Service Hours or Weekly
“ Fuel Tank Water and Sediment - Drain“ . . . . . . . . 97
Initial 500 Service Hours
“ Engine Valve Lash - Check“ . . . . . . . . . . . . . . . . . 89
Every 500 Service Hours
“ Engine Air Cleaner Element (Dual Element/Canister
Type) - Clean/Replace“ . . . . . . . . . . . . . . . . . . . . . . 81
“ Engine Air Cleaner Element (Single Element) -
Inspect/Replace“ . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
“ Engine Crankcase Breather Element -
Replace“ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
“ Fan Clearance - Check“ . . . . . . . . . . . . . . . . . . . . 90
Every 500 Service Hours or 1 Year
“ Battery Electrolyte Level - Check“ . . . . . . . . . . . . 74
“ Cooling System Supplemental Coolant Additive
(SCA) - Test/Add“ . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
“ Engine Oil and Filter - Change“. . . . . . . . . . . . . . . 87
“ Fuel System Primary Filter (Water Separator)
Element - Replace“ . . . . . . . . . . . . . . . . . . . . . . . . . 94
“ Fuel System Secondary Filter - Replace“. . . . . . . 95
“ Radiator - Clean“ . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Every 1000 Service Hours
“ Belt Tensioner - Check“ . . . . . . . . . . . . . . . . . . . . . 75
“ Belt - Inspect“ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
“ Engine Valve Lash - Check“ . . . . . . . . . . . . . . . . . 89
“ Water Pump - Inspect“. . . . . . . . . . . . . . . . . . . . . 101
Every 2000 Service Hours
“ Aftercooler Core - Inspect“ . . . . . . . . . . . . . . . . . . 73
“ Engine Mounts - Inspect“ . . . . . . . . . . . . . . . . . . . 86
“ Starting Motor - Inspect“ . . . . . . . . . . . . . . . . . . . . 99
“ Turbocharger - Inspect“ . . . . . . . . . . . . . . . . . . . . . 99
Every Year
“ Engine - Clean“ . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Every 3000 Service Hours
“ Aftercooler Core - Clean/Test“ . . . . . . . . . . . . . . . 73
“ Alternator - Inspect“ . . . . . . . . . . . . . . . . . . . . . . . . 73
SEBU8731-04
71
Maintenance Section
Maintenance Interval Schedule